You are on page 1of 14

Inter-RAT Cell Reselection

Trial

Objective
To find a good balance between
coverage and performance for LTE by
adjusting UMTS reselection to LTE

Background Information

Idle mode reselection parameters from LTE to UMTS and vice


versa was set to -110 dBm for the market
30% RRC MO-Signaling: UE ping pong from LTE to UMTS
with high RRC failures
Reselection from UMTS to LTE was set to AT&T GSV of -104
dBm while LTE to UMTS was retained at -110 dBm
12% RRC MO-Signaling, reduced RRC failures due to
signaling
20% ERAB attempts lost
6 dB reselection hysteresis may be too high

Summary of UMTS SIB19


Impact

Negligible impact seen on Accessibility and Retainability


Increased RRC, ERAB and S1 Signaling Attempts
RRC Distribution shows a 6% (abs) increase in RRC MO
signaling
Threshhigh at 16 RRC signaling at 12%
Threshhigh at 14 RRC signaling at 18%
Traffic increase
Small Increase in IRAT Session Continuity to WCDMA
Throughput is unchanged

Parameterization

UMTS
Threshhigh 16 (Gold Standard Value, initial value)
Threshhigh 14 (Current Setting)

LTE (idle mode)


EUtranCellFDD: qRxLevMin: -120 (GSV)
EUtranCellFDD: sNonIntraSearch:10 (GSV)
EUtranCellFDD: threshServingLow:10 (GSV)

LTE (dedicated mode)


ReportConfigEUtraBadCovPrim: a2ThresholdRsrpPrim: -115
(Current Setting)

Idle Mode Behaviour


UE reselects to UMTS when RSRP falls below -110 dBm and
UE reselects to LTE when LTE measured RSRP is -106 dBm
Dedicated Mode Behaviour
UE will IRAT to UMTS when RSRP is -116 dBm (-115 dBm + 1
dB hysteresis). UE will remain in LTE longer when in
dedicated mode.

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

SiB19 Performance
Impact

THANK YOU

You might also like