Aldry Arief Budiman, Eva Novianingsih, 2015. Rancang Bangun
Pembangkit Clock Dengan Arduino Dan Power Supply Untuk Peralatan Bantu Praktikum Modulasi Delta, Final Project, Vacational Major Teleommunication Engineering, Department of Electrical Engineering, State Polytechnic of Malang, Malang. Advisor I : Waluyo, Ir., MMT. Advisor II : Rachmad Saptono,ST., MT. Lab equipment in the course of Digital Telecommunications System is a power supply and a generator function that was used to generate a clock signal amount is still inadequate. By designing power supply and design a tool that is used to generate a clock signal as a function generator replacement. The design of the tool is made to add a device practicum course on digital telecommunications systems. Power supply uses a step-down transformer which serves to reduce the electrical voltage or ac voltage in accordance with the requirements of electronic components are contained in a series of DC power supply, rectifier serves to turn the tide of AC into DC after the voltage waveform derived by a step-down transformer, filter used to smooth the voltage DC is out of the rectifier. and a voltage regulator which serves to regulate the voltage so that the voltage output is not affected by temperature, load current and input voltage derived output filter. Power supply is used as a power supply for DM module used in lab delta modulation. Clock signal generator using AD9850 module that serves to generate signals while the box to set or control the frequency using the programming arduino uno. The frequency value will appear on the LCD and to set the frequency using the push button. Keywords: Arduino, Clock, Power Supply