eB SPECIFICATION FOR BEDD
| ocne.:atvacense | OENONSTRATION HZ PSA on arene: on 70
Rev.No: 4 Job No. : 11226 Page : 31 of 47
AM any cosineering
[tube | CS/Low | High Alioy | Non ferrous
Metallurgy | Alloy Steel | (above SCr, % | (Admiralty | Alloys
{upto end | Moand.up | brass, Cu-Ni, |__(Incoloy,
including 5Cr, | through etc.) Titanium, ete.)
% Me) austenitic |
____ |Stainiess steo!) |
Tube diameter | 25/20 25/20 257/20 25/20 | 25
mm (OD) _
Tube zero | 2016 | 206 | tasos | 20
Thickness (min) __ | |
Tube thickness) 23/29 23i23 | 23/23 [| — =
for IBR Service |
Preferred tube OD will be:
20mm for fouling factor < 0.0004 hr-m2.°Cikcal,
25mm for fouling factor > 0.0004 hr-m2-°Cikcal.
5.1.3.3. METALLURGY
5.1.1.3.1 Lube oll cooler for lube oil / seal oil consoles shall be preferably SS 302.
5.1.3.4. FOULING FACTORS.
5.1.3.4.1. FOULING FATORS FOR PROCESS STREAMS
Fouling factors for process streams are decided by licensor / designer based
fon past experisnce and good design practices. However, specific
requirements of Owner are addressed in individual unit design basis
document.
5.1.3.4.2, FOULING FACOTRS FOR UTILITY STREAMS