current filter specifications and design method by opening the Filter Visualization Tool (fvtool) from Signal Processing Toolbox software. For more information about FVTool, refer to Signal Processing Toolbox documentationother one 3mm.. It is important to note that both structure s have been retuned to 2100 MHz to compare them. As it was already mentioned, the radiation efficiency is useful to compare different systems. Figure 5.4 provides the radiation efficiency of the structure without dielectric,Filter Response Displays the magnitude response for the current filter specifications and design method by opening the Filter Visualization Tool (fvtool) from Signal Processing Toolbox software. For more information about FVTool, refer to Signal Processing Toolbox documentation and with 2mm. and 3mm. wide dielectrics. When the dielectric is wider than 3mm the shift to low frequencies is bigger and is not possible to retune to high frequencies without losing bandwidth. In this cases, it is imp ossible to cover all the band. Based on the results, this dielectric walls do not improve the total efficiency of the system. Although with dielectrics lower values of S21 are achieved, also the input imped ance matching S11 is worse, thereby, asFilter Response Displays the magnitude response for the current filter specifications and design method by opening the Filter Visualization Tool (fvtool) from Signal Processing Toolbox software. For more information about FVTool, refer to Signal Processing Toolbox documentation