Professional Documents
Culture Documents
Annunciator Modules: ACM-16AT, ACM-32A, LDM-32 & LDM-R32
Annunciator Modules: ACM-16AT, ACM-32A, LDM-32 & LDM-R32
ACM-16AT, ACM-32A,
LDM-32 & LDM-R32
Intelligent/Addressable Devices
General
The Notifier ACS Series Annunciators
provide a modular line of products for
annunciation and control.
ACM-16AT
These may be used for isolate/de-isolate
functions or as test switches for solenoids
or any switchable devices.
Features
Communications and Communications
Fail LED indication.
Lamp test button.
16 touch pad switches.
Switches may be set in banks of 8 to
either toggle on/toggle off or
momentary modes.
16 red and 16 yellow LEDs.
ACM-16AT
ACM-32A
This module may be programmed to show
the status of any point, zone or module on
the system.
Features
Communications and Communications
Fail LED indication.
Lamp test button.
32 red LEDs.
ACM-32A
Page 1 of 2 DOC-02-034
LDM-32
The Notifier LDM-32 Lamp Driver Module is
for use as a site specific mimic panel or
wherever LED annunciation is required.
Features
32 alarm lamp-driver transistors (sink to
power common on alarm).
May be powered by 24 VDC from the
panel or by remote power supplies.
Efficient switch-power converter reduces
power consumption.
Microprocessor-controlled electronics,
fully supervised.
Plug-in terminal blocks for ease of
installation and service.
LDM-32
LDM-R32
Notifier's LDM-32R connects to the LDM-32
for electrical isolation when interfacing the
system to other equipment such as EWIS
or wherever a large number of relays are
required.
Features
Converts the LDM-32 transistor outputs
to 32 dry contacts (1.0 A @ 30 VDC).
Provides 32 output terminal screw
connections and a single common
terminal screw.
LDM-R32