You are on page 1of 2

Display

SGW Control IP
SGW Control TEID
MME Control IP
MME Control TEID
Active Peer
State
SGW S5 C IP
PGW S5 C IP
SGW S5 C TEID
PGW S5 C TEID
Session State
Session Duration
NSAPI/EBI
SGW Access Data IP
eNodeB Data IP
SGW Access Data TEID
eNodeB/RNC Data TEID
SGW S5/S8 Data IP
PGW Data IP
SGW S5/S8 Data TEID
PGW Data TEID

Display Info
Control plane IP address of the S-GW on the S11 interfaces.
Control plane Tunnel Endpoint Identifier (TEID) of the S-GW on the S11 interfaces.
Control plane IP address of the Mobility Management Entity (MME) on the S11 interface.
Control plane TEID of the MME on the S11 interface.
Indicates whether the MME or the SGSN is actively sending control messages to S-GW.
State of the subscriber: idle, active, or suspended.
IP address of the S5 GTP-C tunnel on the S-GW side to which the PDN Gateway (P-GW) will send contro
IP address of the S5 GTP-C tunnel on the P-GW side to which the S-GW will send control messages for
TEID of the S5 GTP-C tunnel on the S-GW side. The P-GW sends this TEID in the GTP header in all cont
TEID of the S5 GTP-C tunnel on the P-GW side. The S-GW sends this TEID in the GTP header in all cont
State of the subscriber session on the signaling plane.
Duration of the PDP session.
Network Service Access Point Identifier (NSAPI) or the Evolved Packed System Bearer ID (EBI) for the s
Data plane IP address of the S-GW on the S1u interface.
Remote data plane IP address of the peer on the S1u interface.
Data plane TEID of the S-GW on the S1u interface.
Remote data plane TEID of the peer on the S1u interface.
IP address of the S-GW to which the P-GW sends the data packets for the bearer.
IP address of the P-GW to which the S-GW sends the data packets for the bearer.
Data TEID allocated by the S-GW that identifies the data tunneling endpoint for all data packets comin
Data TEID allocated by the P-GW that identifies the data tunneling endpoint for all data packets comin

You might also like