Four factors are required to be achieved if a safe workplace is to be achieved during
steelwork erection, namely:
(1) A sound plan set out in a written erection statement; (2) Adequate resources in terms of people and equipment; (3) Competent individuals, suitably trained and experienced; (4) A chain of command to enable clear instructions to be given. The critical erection stages for temporary demountable structures should be identified during the design process. To ensure adequate provision against overturning during erection, temporary strutting and/or guying may be necessary. Such requirements should be adequately communicated to the site operatives. An Erection Method Statement, together with drawings, is recommended for this purpose DISMANTLING The dismantling of a demountable structure is important since its components are likely to be reused. Care should be taken to maintain the safety of the dismantling team and other people nearby. The critical erection stages should have been identified during design. The safest dismantling plan will normally be to reverse the erection procedure. This should prevent components from being bent, distorted or overstressed during dismantling. Minor damage to the structure may have occurred whilst in service and the damaged components should have been clearly marked for ease of identification when dismantling. During dismantling, the contractor should examine all components for signs of wear, deformation or other damage. Damaged components, or those with temporary repairs, should be set to one side for rejection or permanent repair off site.