technology The regulator has three printed circuit boards or connection levels.
Optical Serial Protocol Interfaces
For fibre optic serial connections up to a baud rate of 19200 (e.g. DNP, IEC 60870-5-101 or 103), ST or FSMA connectors are directly mounted on the flange plate for access without opening the REG-DA door. Please refer to the list of characteristics for an overview of the available options.
The auxiliary voltage, the VT & CT inputs, as well as the relay
outputs, binary inputs etc., are all connected on Level I. The hardware for all SCADA connectivity is on Level II. When working with an Ethernet connection (such as for IEC 61850, IEC 60870-5-104 or DNP 3.0 over Ethernet), the corresponding plug connection is also accessible on Level II (RJ45 and/or ST/LC fibreglass). Additional binary inputs and outputs, and mA inputs and outputs can also be installed on Level II. There are two slots available, each of which can be equipped with the following modules: Module 1 : 6 binary inputs AC/ 48 V...250 V Module 2 :
6 relay outputs
Module 3 :
2 mA inputs
Module 4 :
2 mA outputs
Module 5 :
PT100 input
Module 6 :
Standalone monitoring unit PAN-A2
occupies both slots
Fibre optical connection (ST-connector, V17, V19)
The connections for the REG-DA COM ports, the E-LANs,
additional analogue inputs and outputs, as well as for the PT100 direct input (E91 + E94) or resistance input (E97 + E98) cards, are located on Level III.