Professional Documents
Culture Documents
5
3
4
1. Dimensions should be uniformly placed (50 and 60 should be vertically
aligned).
2. 10 cant cross the dimension line
3. Dimension should be pulled outside of shape.
4. Dimension should be pulled outside of shape.
5. 30 should be horizontally placed.
2. There are 4 types of dimensioning mistakes. List them and then explain the
4
reasons.
3
7
1. 1.50 should be pulled out farther; .50 should be pulled in closer, in front
of the 1.50
2. Centerline cant continue between two views; there should be a break in the
line.
3. Leader line should extend through the center of the circle.
4. For consistency, 1.00 should be put between the dimension lines.
3. Are there any duplicate dimensions in the following figure? If there are, which
duplicate dimensions should be deleted?
1
6
4
5. Dimension the following part. Use SolidWorks create the part, and post the
drawing imagine here.
6. Dimension the following part. Use SolidWorks create the part, and post the
drawing imagine here.