1. Solve Problem 7.4 in the textbook using Ansys. Use mesh controls and/or adaptive refinement to ensure that the results of your analysis are converged. Please include the following: a. the analysis log file, b. fringe plot of total deformation, and c. fringe plot of von Mises stress. (10 points) 2. Use Ansys to solve the thick-walled cylinder problem as shown below. Model this problem in three different ways: 3D, 2D plane strain and 2D axisymmetry problems. Make sure you achieve convergence in each of these cases. For each case, please submit the following items: a. the analysis log file, and b. radial stress r fringe plot. Also create a table that compares the maximum von Mises stresses for the three cases. (15 points)
3. Plate with an elliptic hole revisited
Perform a parameter study with half of the minor axis b of the elliptic hole as the parameter. Run the sensitivity study with 9 steps for the range of b = 0.1 to 1.0. Submit a parameter chart of xx vs b. Comment on how changing b would affect the stress concentration factor. Note that at b = 0.5 (major axis = minor axis a circle), xx should be the same as the result from the previous assignment. Use steel as the material for the plate. (10 points)