Professional Documents
Culture Documents
8K Clock Source Lost
8K Clock Source Lost
Product
Network
IOMCRV6.20.614HManagement
OMCBV4.00.200M-0718.zip
Version
Equipment
iBSCV6.20.614D.zip
Software Version
Board Software
Version
Equipment
Hardware Version
Board Hardware
Version
Incident Error
Page Views
10
Code
Author
WangShiHao
Knowledge No.
WHD20120614394409
Incident Description (Incident Phenomena)
BSC 8K clock source lost ,and the clock board phase-lock loop work mode abnormal .
Networking Environment
Problem Cause Analysis
1.CLKG board fauty .2.Clock extracting cable issue .3.Transmission clock issue.
Solution
1Check the clock extracting cable on both SDTB&CLKG sides,it is connected firmly and not
break down!
2Change the clock extracting cable and check again ,the 8K clock not get normal
3Check the CLKG hardware version ,make sure the extracting cable physic connect is
correct
.
4. Handover the slave CLKG to master and check again ,the 8K clock not get normal
.
5. Check CLKG board printing ,it is showing as follows ,it is alreday exceed limits ,the clock
frequency should between -4.6ppm to +4.6ppm ,that's why our BSC can not trace the 8K
clock .
I1 : Prioity = 0 ; State = ActAlm ; Freq Offset = -487.679993 ppm
I2 : Prioity = 0 ; State = ActAlm ; Freq Offset = -487.679993 ppm
I3 : Prioity = 0 ; State = ActAlm ; Freq Offset = -487.679993 ppm
I4 : Prioity = 0 ; State = ActAlm ; Freq Offset = -487.679993 ppm
I5 : Prioity = 0 ; State = ActAlm ; Freq Offset = -487.679993 ppm