Professional Documents
Culture Documents
can crack
Creep may be the most common cause
BY RAYMOND A. DIPASQUALE
ARCHITECT/STRUCTURAL CONSULTANT
nvestigators of cracking problems in concrete structures have from time to time noticed horizontal and
vertical cracks in concrete columns. How does this
happen when cracking indicates tension in the concrete whereas columns usually are in compression?
Tension a possibility
Ruling out pure compressive overload, there are three
possible explanations. First, the columns may in fact be
in tension due to an isolated settlement of the foundation. In this case, the column could be hanging from
the floor system above, resulting in tensile cracking.
Next, if the column is the end or exterior one in a
structural bent or frame, it may have high enough bending to cause tensile forces in the outside face. This condition would produce horizontal cracks which would
disappear on the inside face.
Creep behavior
The third and most likely explanation has to do with
creep and shrinkage. Both are related phenomena. Under constant compressive stress, concrete continues to
deform with time. The rate of this time-dependent deformation (strain), which is called creep, depends on
many factors. Here are some of them:
The magnitude of the sustained stress; the higher the
load, the greater the creep.
Stress redistribution
With this as background, what really happens in a reinforced concrete column is that creep causes the concrete to unload its compressive stress and transfer it to
the reinforcing steel. In other words, a redistribution of
Creep increases rapidly when
load is first applied, then
increases more slowly as
time goes by, and finally
shows little or no change at
extended durations of
loading. Data adapted from
Hardened Concrete: Physical
and Mechanical Aspects, by
Adam Neville, published by
the American Concrete
Institute, Detroit, 1971;
based on concretes stressed
at 1000 psi.
the amount of prestress, and in tall buildings differential creep can cause movement and cracking of partitions or other structural effects in beams and slabs, the
overall picture is that creep, unlike shrinkage, is beneficial in relieving stress concentrations and has contributed considerably to the success of concrete as a
structural material.
Acknowledgement
Reprinted with permission from Building Failures Forum, Vol.
1, No. 4, January 1981.
PUBLICATION #C810737
Copyright 1981, The Aberdeen Group
All rights reserved