ENTHUSIAST’S RESTORATION MANUAL SERIES
, 7-7-7, To work adequately, the friction plates - ike a very smal luch lste-mty,
7-74. You can now liftoff the uppermost good condition where they bear on the stud plate. The spring that hols them a,
part ofthe damper assembly. ‘must also be sound and unbroken.
7-7-8, Graeme now refits the pressed steel
‘ut to provide the necessary pressure on
1 Wis neering ts sos iaismumenente,
ra ee ee ranean mene
and the central actuator disc must fit over Melos pe csaperaamaleibe
7-7-41, When fitted on the vehicle, the thread when se
friction damper has to be rotated so
that the slots align with the lugs in
the axle. This is Graeme's version of
special tool 3451-T which pushes into
the holes provided in the damper. Once
located, the securing bolt holes can be
aligned with the other end of the tool.
7-17-12, When properly seated, this
is how the lugs should appear
through the slots in the damper.
116ENTHUSIAST’S RESTORATION MANUAL SERIES
7-7-7. To work adequately, the friction plates = like a very small clutch plate- muse,
7-7-6, You can now liftoff the uppermost good condition where they bear on the stud plate. The spring that hols them gen
part of the damper assembly ust also be sound and unbroken,
7-7-8. Graeme now refits the pressed stee!
‘nut to provide the necessary pressure on
the damper. 77-10. Still in is test ig, the dangers
tested to determine the correct amo?
force required to turn it. When the ste
has been given the correct amour
Saomiae pans eiioecrats
selene esate fierce
7-7-11. When fitted on the vehicle, the thread when set
friction damper has to be rotated so
that the slots align with the lugs in
the axle. This is Graeme's version of
‘special tool 3451-T which pushes into
the holes provided in the damper. Once
located, the securing bolt holes can be
aligned with the other end of the tool.
7-7-12, When properly seated, this
hhow the lugs should appear
through the slots in the damper.
116