CEMENT & CONCRETE PRODUCTS™
CONCRETE Mx
Proouct No, 1101
PRODUCT DESCRIPTION
QUIKRETE” Concrete Mix is a pre-blended mixture of cement and aggregates for general
structural uses, requiring only the addition of water.
PHODUCL USE
CQUIKRETE® Concrete Mixis designed for pouring concrete 2° (St
1mm) thick or more and building or repainng anything out of concrete,
including:
+ Foundation walls and footings
+ Sidewalks, curbs, steps, ramps and walkways
+ Appliance and equipment platforms
+ Pipe and post footings
+ Flor sibs and patios
+ Pools, sh pools, stepping stones
+ Splasholocks and bid baths
+ Rirap & slope protection
+ Driveway repairs
SIZES
+ QUIKRETE” Concrete Mi is eallable in
40 fo (18.1 kg) bags
60 fb (27.2 kg) bags
£80 Io (36.3 kg) bags
YIELD
+ An 80 Ib (36.3 kg) bag yields approximately 0.60 cut (17 L)
+460 lo (27.2 kg) bag yields aporoximately 0.45 ou ft (12.7 L)
+840 lo (18.1 kg) bag yields approximately 0.30 cu ft (8.5 L)
TTEGHNIGAL DATA
‘APPLICABLE STANDARDS
ASTM international - ASTM C367 Standard Specifications for
Packaged, Ory, Combined Materials for Morar and Concrete
PHYSICALICHEMICAL PROPERTIES
QUIKRETE” Concrete Mix exceeds the compressive strength
requirements of ASTM C387, as shown in Table 1
TABLE 1 TYPICAL COMPRESSIVE STRENGTH!
Compressive strength, ASTMC39
fee Typical Values:
7 oays 700 psi (17.2 MPa)
28 days 4000 psi (27.6 MPa)
‘Stump Range 2-¥ (o1-/mm)
"Tested undarInbOBDT Canons Warton WH ASTM CHET
DIVISION 3
Structural Concrete
03 31 00
INSTALLATION
PREPARATORY WORK
Stake out the planned area and remove so or soto the desired
Gepth, Nail and stake forms securely in place. Tamp and compact he
sub-base unil firm
MACHINE MIXING INSTRUCTIONS
‘QUIKRETE® Concrete Mic can be mixed in a barr! type concrete
mixer ora mortar mixer.
+ Choose the mixer size most appropriate forthe siz ofthe ob to be
done
+ Allow at least 1 cut (20 L) of mixer capacity for each 80 Ib (36:3 kg)
bag of QUIKRETE” Concrete Mix tobe mixed atone time
+ For each 80 Ip (96:9 kg) bag of QUIKRETE® Concrete Mix tobe
mixed, add approximately 6 pt (2.8L) of fresh water to the mixer
+ Tum onthe mixer and begin adding the coneete tothe mixer
«Ifthe material becomes too dfficulto mix, add addtional water until
a workable mixis obtained
+ Ifa slump cone is avaiable, adjust water to achiove a 2*- 3° (61-78
mm) slump
Note - Final water content should be approximately 6-9 pt (2.8-4:3
{U of water per 80 Ib (36.3 kg) bag of concrete. For other bag sizes,
Use Table 2to determine water content
HAND MIXING INSTRUCTIONS.
+ Empty concrete bags into a suitable mixing container
+ For each 80 Ib (36.3 kg) bag of mix, add approximately 6 pt (2.8L)
of clean water
+ Work the mix with a shovel, rake ot noe and add water as needed
na tif, moldable consistency is aclieved
+ Be sure all serial is wel
+ Do not eave standing puddles
Note ~ For other bag sizes, use Table 2 to determine water content.
al"TABLE 2 MIXING WATER FOR QUIKRETE® CONCRETE MDC
Package size, Ib (kg) Stating Water Final Water,
Content, pt(l)___ Content, pt (U)
sa) 628) 6528-43)
60 (27.2) 4119) 471.933)
40 (181) 31g) 345 (1471)
APPLICATION
Method for Pouring a Slab
+ Dempen the sub-grade before concrete is placed
+ Do not leave standing puddles
+ Shovel or place concrete into te form: flo the full depth ofthe
form
+ After concrete has been compacted and spread to completely fl the
forms without air pockes, strike off and ft immediately
+ To srke off, use a straight bod (soreed), moving the edge back
and forth witha sawelike mation to smooth the surface
* Use a darby or bul oat to loa the surtace; tis levels any ndges
and fils voids eftby the straightedge
* Cul te concrete away frm te frm by unig an edging tool oF
Uwywel ang te fos lo compact the slab edges
+ Cut 1" (25.4 mm) deep contol joints int the stab every 6-8 (1.8 -
2.4 m) using a grooving tool
+ Alow concrete to sien sight, waiting unt ll water has
‘evaporated from the surface before trowelin or applying a broom
finish
Note - For hest ruts, de nat everwevk the material
Method for Setting Fence Posts,
+ Dig post hole about 3 times the diameter ofthe post. Hole depth
shouldbe 1/3 the overall post height
+ Place (152 mm) of cry concrete mixin the bottom of the hole
Postion the post, cecking that tis level and plumb, Combine
concrete mix with water and place into the ole
+ When standing water has evaporated from the concrete, smooth the
surface. Tape it away rom the 20s so rain wil win hat recon
Walt 24 nours before posts sutjected to any strain
+ For load-bearing applications, ‘low local bulding codes for proper
footing specications
FINISHING
‘Any standard concrete nishing technique is acceptable for use with
‘QUIKRETE® Concrete Mix. Concrete can be hand troweled, power-
troweled, broom fnished or frisved with other specialty fishes.
cURING
General
Curing is one of the most important steps in concrete construction.
Proper curing increases the strength and durabily of concrete,
‘and a poor curing job can ruin an otherwise welldone projet. Proper
water content and temperature ae essential for good curing. in
near freezing temperatures the hydration process slows considerably
\When weather is foo hot, dry or windy, water is ost by evaporation
from the concrete, and hydration stops, resulting in finishing
difcuties and cracks. The ideal cicamstances for curing are ample
moisture and moderate temperature and wind conditions. Curing
should be started as soon as possibe and should continue for a
petiod ofS days in warm weather at 70°F (214C) or higher or 7 days
in colder weather at 50 - 70% (10 -21:C).
‘Specific Curing Methods
“ QUIKRETE® Acryic Cure & Seal -Satn Finish provides the easiest
and most convenient method of curing. Apply by spray, brush o oll
soon after the final fishing operation when the surface is hard. The
surface may be damp, but not wet, when applying curing compound.
Compete coverage is essential
+ Other methods of providing proper curing include covering the
surface with wet burlap; keeping the surface wet with a lawn sprinkler
and sealing the concrete surface wit plastic sheeting or waterproof
paper to prevent moisture lass
+ If burlap is used, it shouldbe ree cf chemicals that could weaken or
discolor the concrete. New burlap should be washed before use
Pace it when the concrete is hard enough to withstand surface
cdamage and sprinkle it periodically to Keep the concrete surface
continuously moist
+ Water curing wih awn sprinklers, nozzles or soaking hoses must be
‘continuous to prevent interupton ofthe curing process
+ Cunng wih plastic sheets is convenient. ney must be tid at,
thoroughly sealed at joints and anchored careful along edges
PRECAUTIONS
+ Curing compounds should not be applied i rain or temperatures
below S0-F (10°C) are expected win 24 hours
+ Curing with plastic or burlap can cause patchy discoloration in
colored concrete, For colored concrete, wet curing or the use of
(QUIKRETE® Aeryic Cure 8 Seal ~ Satin Finish is reeammensied
+ Do nat use curing compounds during fat fal on surtaces where de-
ice wil be used io melt ie and snaw. Using curing compounds at
that ime may prevent proper air crying ofthe concrete, which is
necessary to enhance is resistance to damage caused
by de-cers
+ Protect concrete from freezing during the frst 48 hours. Plastic
sheeting and insulation blankets shauld be used i temperatures are
expected to tll below 32% (0-0)
WARRANTY
The QUIKRETE® Companies warrant this product to be of
‘merchantable qualty when used or applied in accordance with the
instructions herein. The product is not warranted as suitable for any
purpose or use other than the general purpose for which itis
intended. Lisbiliy under this warrarty is limited tothe replacement of
its product (as purchased) found tc be defective, or atthe shipping
‘companies’ option, to refund the purchase price. In the event of a
claim under this warranty, notice must be given to The QUIKRETE®
Companies in wring. Ths ited warranty is issued and aocepted in
lieu ofall other express warranties end expressiy excludes lability for
consequential damages,
The QUIKRETE® Companies
Ove Secuites Cente
3490 Pedmoni Ra, NE Suite 1300, Ana, GA 3005
(404) 634-9100 «Fax 04 842-1425
ete to mn qute came the mas cure ei deta, MSS, ana gue specs