Professional Documents
Culture Documents
RJ45 Ethernet Port MODEM Pool Uses Operating Instructions
RJ45 Ethernet Port MODEM Pool Uses Operating Instructions
Click Server
2. Click Next.
You can choose to install the required target directory location , or use the
installation program the default installation directory
3. Click Next
4. Click <Next>
6. Then click "Finish" to complete the installation After installation is complete , start -to-end
server configuration.
Second, configure the IP browser 1, in the IE browser, enter your modification good IP
(http://xxx.xxx.xxx.xxx). FIG.
2 , click open mode - port , the default is TCP realport, selected it as MCP operating
mode , then " settings to all port " check in the box , and click Submit. As shown
below.
3, select Input Manually, enter the IP address , the lower right Total Prots is how many virtual
COM ports . For example, I was four MODEM pool. I am here to write
4 . If you're eight MODEM pool , you can enter 8 . As shown below
4. When all is set up click OK, and then Yes you can .
5 , and finally into the browser, click to reboot the device . As shown below