Professional Documents
Culture Documents
Transmission Belt PDF
Transmission Belt PDF
Transmission Belt
Open a new part with model units set to
millimeters.
Go to: File > New > Part
Select the Front Plane and create a sketch by clicking on the 2D sketch icon
The display changes so the Front plane faces you.
The Sketch toolbar commands appear in the CommandManager.
A sketch opens on the Front plane.
Draw a circle
Click at the circle icon
Click to place the starting point of the line. Move the pointer. Notice that it displays
the current dimensions of the line. Draw the two lines as shown in the picture. The size
of your sketch entities does not need to be exact.
3 | Page
Repeat this action for the other sides of the lines and circles as shown in the picture.
4 | Page
NOTE:
Because a basic knowledge of SolidWorks is required to participate the tutorials
of SolidWorksModel we will left all the small steps in the 2D sketch environment
away in the future.
We do everything we can to keep the SolidWorksModel tutorials as clear and
bright as possible. If we describe every click as above then the tutorial would be
very thick and dull. To prevent this, weve decided that SolidWorksModel
participants should be capable enough to draw a simple 2d sketch with an
example picture of SolidWorksModel like the three examples below.
If you have problems with the 2D sketch features we recommend you to practice
the basics of SolidWorks 2D sketching first.
Here you could find some basic SolidWorks tutorials:
Go to: Help > SolidWorks Tutorials > Getting started > Select a lesson
You could also practice some excellent basic tutorials of SolidWorks itself which
could help you to discover the basics of SolidWorks.
You could download those tutorials here:
Tutorial 1 Create an Axis
http://blogs.solidworks.com/files/solidworks_tutorial01_axis_english_08_lr-2.pdf
Tutorial 2 Create a Picture Holder
http://blogs.solidworks.com/files/solidworks_tutorial02_pictureholder_english_08_lr2.pdf
Tutorial 3 Create a Magnetic Block
http://blogs.solidworks.com/files/solidworks_tutorial03_magneticblock_english_08_lr1.pdf
Tutorial 4 Create a Candlestick
http://blogs.solidworks.com/files/solidworks_tutorial04_candlesticks_english_08_lr.pdf
5 | Page
: Blind
Change
into 88 mm
: One-Direction
Change
into: 3.5 mm
The yellow selection shows the direction of the extrusion. If you want
to change the direction, click on the red arrow in the Thin Feature
toolbar.
Click OK
NOTE:
When you encounter problems with the 3D sketch features, we recommend you to
use the SolidWorks files of SolidWorksModel as an example and reference file.
6 | Page
Create a fillet
Select the four green edges as shown in the picture.
SolidWorks automatically selects the other edges of these corners.
Those are marked in yellow.
Go to: Insert > Features > Fillet/Round
> 1 mm
Click OK
Save