You are on page 1of 8
PRO METAL DETECTOR 37" DETECTOR EXTENDS TO 49" CAUTION: Battery Operated Toys. Not recommended, for children under 10 years of age. Precautions should be observed coring handing and tbe to prevent sloctre shock: aa SS * Dual operational mode for metal and non-metal findings Ablity to distinguish between metal and non-metal objects * 5 LED's to help classify objects (Iron, Copper, Gold, Silver, Aluminum, etc.) * Tone-assisted to indicate object intensity * Ground balance for more accurate sensitivity adjustment * Knob for fine-tuning object distinction * Knobs for sensor sensitivity adjustment and tone volume control + Auto battery flat detection LED presentation area for object classification ‘SENSITIVITY ADJUSTMENT knob ‘Operation mode indicator for “ALL METAL” Operation mode indicator for “DISTINCTION OPERATION MODE SELECT button. GROUND BALANCE RESET button POWER ON/OFF and VOLUME CONTROL knob FINE-TUNE knob for object distinction (Output Jack for headphone (Note: headphone not included) e0eeseoee +f @ and @ are blinking at the same time during normal use, there is a LOW BATTERY level detector. 1 INSTRUCTION TO BATTERY OPERATED TOY: ‘+ For best performance use only the batteries recommended. Do rot use rechargeable batteries. Ensure batteries are inserted with the correct polarity. Do not mix diferent battery types. Do not mix new and used batteries together. Remove batteries when toy is notin use. Remove exhausted batteries from toy and dispose of in accordance with the makers recommendation. Do not attempt to recharge non-rechargeable batteries. This supply terminals are not to be short circuited. Do not mix old and new batteries. Do not mix alkaline and standard (caroon-zine) or rechargeable (nickel-cadmium) batteries. BATTERY INSTALLATION 1.Open the battery compartment by 2, Place the "8 Volt” battery into the using a Philips screwdriver in a battery compartment. counterclockwise direction, 3. ‘8. Close the battery compartment 4. you experience the LOW by using the Phillips screwdriver BATTERY indicators blinking ina clockwise direction during normal use, replace the battery, US eeu =a 1. Tum the stem’s lock nut clockwise until it becomes loose. 2. Adjust the stem length when you stand ‘upright with the detector in your hand. For the best search performance, you should always. keep the search coll to 2 inches above the ‘ground with your arm relaxed at your side. SEARCH COIL ADJUSTMENT 3. Turn the stem's lock nut counterclockwise to lock it in place. 1. Tum the search coils lock 2. Adjust the search col when 3. Tighten the search coils rut clockwise unti it you stand upright with the lock nut counterclockwise becomes loose,

You might also like