6/5/56
Siena Gesor
‘oan
1. High side clipped to
body of 15 mmf (on
‘gid of 603) (B), low
‘eto ground.
2 High side lipped to grid
of 6AU6(V5) (D), low
Side to ground.
13. High ide lipped to gid
‘of 6AUS(VS) (D), ow
‘ds to ground
4 High side through 270
‘hm carbon restor to
15. High side through 270,
hm carbon resistor to
fates, low side to an
enna ground terminal
Sie en
10:7 me 500
KC sweep
10. me CW
1037 me CW
106 mo, 75
KC deviation
400 ps rate
92 me, 75 KC
deviation,
400 epe rate
330.C_ ALIGNMENT INSTRUCTIONS
(Refer to circuit diagram for alignment est points)
Tee Dal — comes
a Sor ie, Ao
109 me (C) and (C) and ground AL TF trans
exoand
100 me Coytl probe
coupled los
cope tat tr
EAUGIVS) (aot ol
touching)
109 me High to (F) lon Secondary of
to fonction ot decor tre
to 10000 ohm former (ap)
106 me Oatpst_— AC VTVM tll “Front
Cable bait able End” timer
92 me Output AC VIVM to Alliber plated
Cale output cable “Front Ead™
cele by expand
fan or orapw
sing esl tome
Note: Alignment tobe done with Level Contra fully lackwise,
aaa ase ace ao aa
Connect 21o Smad paper capacitor
between (A) and giound. Adjust
for maximum amplitude and sym
rmety. Use lowest input level to
tbtain adequate output (maximum
55V de)
Adjust for maximum defectio
Connect 1000 ohm earbon resistor
between (HH) and (I) (second
ary) inp level between 05 and
Pst
Adjust for 0 (zero) deletion.
Connect two matched. 100,000
‘hm resistors in series Connect
this between (G) and ground,
Signal generator output level 6
Imlerovolle Adjust trimmer for
Signal generator ontpt level 6
Imleravolta Adjost for maximam
audio output, then repeat 4,
(approx. 25. vol on VIVM),330-C CIRCUIT DIAGRAM
HERMON HOSMER SCOTT, INC.
111 Powdermill Road - Maynard, Mass. Form 00B-cD-156