The use of "tooth jewelry" can be placed on a tooth without cutting into the
natural tooth structure. Costume "diamonds" or real diamonds can be placed on
the tooth surface. The cut glass of costume diamonds have a flat base and a real diamond needs to be wide and flat NOT tall. Materials needed: Curing light-with eye protection cone. Light cured Sealant** ( clear non-filled and non-yellowing ) Etch* 1. For natural teeth use 20 - 37% Phosphoric acid. 2. For porcelain use porcelain etch. 3. For metal use microetch, bur or metal etch. Gloves Cotton rolls Water Brushes Tweezers Alcohol Facial tissue Toothpicks Hard wax rod for pickup of gem Knife or clippers for trimming mold
Add a sparkle to your smile!
Your dentist can become your personal Jeweler of Your Mouth Up To Top Technique 1. Brush teeth. 2. Pick which tooth and the location on the tooth that you would like placement of the jewel. 3. Check bite for any interference (cross bite, end to end bite, etc.). 4. Isolate area ( with cotton roll ) to keep it dry from saliva, hands, gloves, powder, oils, etc.
5. ** Etch entire surface of tooth, including incisal edge, for 10 seconds, DO
NOT RUB. ENTIRE TOOTH MUST BE ETCHED. DO NOT PUT ANY SEALANT ON ANY UNETCHED AREA. 6. Rinse and dry, keeping tooth isolated with cotton roll. 7. Reapply the etching for 10 seconds, then blot, DO NOT RUB. This is for the best bond. NOTE: ETCHED AREA SHOULD APPEAR FROSTY WHITE. 8. Rinse and dry, keeping tooth isolated with cotton roll. 9. Must re-etch if contaminated by saliva, etc. 10. Apply a thin layer of sealant to etched area, and light cure 10-20 seconds. 11. Apply sealant to back of mounted diamond and onto tooth. Place diamond. 12. Before curing, position the diamond in the desired location, positioning for best light reflection and maximum sparkle when the patient is facing directly forward. 13. Light cure for 20 seconds. 14. Add thin layers of sealant around the diamond to make the surface smooth. Light cure for 10 seconds after applying each layer. After filling in around the diamond add at least 3 layers of sealant over the entire tooth surface and the diamond, curing after each layer. 15. Finish with a final light cure for 30 seconds, then rinse. 16. Keep smiling and show off your tooth gem. 17. There is absolutely no noticeable sensation. One or two days and it feels natural again.