Vidyarthiplus Important Questions
‘Anna University, Chennai
Department of B.£ Mechanical Engineering
B.E/B. Tech, DEGREE EXAMINATION May/June 2016
‘SIXTH SEMESTER
ME6601 Design Of Transmission System
(REGULATION 2013)
1
Design a chain drive to transmit 6 KW at 900 rpm of a sprocket pinion. Speed reduction’
Driving motor is mounted on an adjustable base. Assume that load is steady, drive i intal and
service is 16 hours/day.
2
Design a flat belt drive to transmit 25 kW at 720 rpm to an aoa AQP Fectine with a speed
reduction of 3.0. The distance between the shafts is 3 m. = ing machine pulley is 1.2m.
‘A compressor is to be actuated from a 10 KW electric cet of the motor shaft is 1000
rpm and the compressor speed being 350 rpm .the centre distance is S00 mm. the
compressor operates 16 hours per day. Design a xe jain drive.
4,
Design a v- belt drive and calculate the a It tension and average stress for the following data.
Driven pulley diameter, D = 500 ulley diameter, d=150 mm, center distance C= 925 mm,
speed Ni =1000 r.p.m, N2 ae power,
jate a compressor from 2.12 kW electric motor at 900 r.p.m , the
|. Minimum centre distance should be 500 mm, the chain tension maybe
The pitch circles of a train of spur gears are shown in fig 3.gear A receives 3.5 kW power at 700 r.p.m
through its shaft and rotates in clock wise direction .Gear B is the idler gear while gear Cis the driven
gear. The number of teeth on gears A, B and C are 30, 60 and 40 respectively, while the module is 5
mm. calculate the torque on each gear shaft; and the components of gear tooth forces.
7,
{Ina spur gear drive for a rock crusher, the gears are made of case hardened alloy steel. The pinion is
transmitting 18 KW at 1200 r.p.m with a gear ratio of 3.5.The gear is to work 8hours/day for 3 years.
Design the drives major dimensions, check for compressive and bending stresses and sketch the
arrangement.A motor shaft rotating at 1440 rpm has to transmit 15 kW to a low speed shaft rotating at 500 rpm