Professional Documents
Culture Documents
I.
The routers LED all on but only one LAN port is connected
The routers LED all off or only power light on but LAN port is connected
Solution (CW-5354u):
1. Copy correct firmware to My Computer at drive C:\.
Right-click on the Local Area Connection icon and choose Properties from
the pop-up
menu.
4. The LAN port LED light should be blinking, below command line will show up.
5. This means the firmware has been transfer successfully and waits at least 3
minutes before access back into the web management page.
Note: change your IP settings to DHCP before you open the router interface.
6. After 3 minutes, open Internet browser such as Internet Explorer, Mozilla,
Google Chrome, etc. and log back in to 192.168.1.1, you will notice that the the
firmware has been updated. (See upper right side of the web page).