EEE 302 Principles of Communications 7 May 2016
FINAL EXAM
SOLD TIONS
Q1.(25 pts) a. Determine the frequency response of high-pass RC filter given
below: oe 2
Va AL Vo
R
forte) FRAC
Gi ee ee
Nance) (4 gta PC
b. An FM wave
Se
s(0) = A, cosl 2af.t + 2k, [' m(r)dz]
is applied to the system consisting of above RC filter and an envelope detector
as shown below. Assume that resistance R is small compared with reactance of
capacitor C for all significant frequency components of s(t), and the envelope
detector does not load the filter. Determine the resulting signal at envelope
detector output assuming that k,|m(t)| < f, for all t.
% eA -—~,
Ervdlepe] Sy
eo) Idelector| —~®
anpac ced , tf pave
fae ( Lippanstions—)
urn RK seat,
MEY EF
ae paren rer,
ae
mlegent si
jeune ROSIE 2 0c Orff 2g )sin(
Le
-&
paleo dike (hewe]
Encrleye de OEH oubpy
Wo 2K
nei + ke ety) :
feEEE 302 Principles of Communications 7 May 2016
Q2.5 pts) A message signal m(t) is transmitted through an AWGN channel
using SSB modulation. The power spectral density of m(1) is
Su(N= alll, \n Pete
GWNsEEE 302 Principles of Communications 7 May 2016
Q3.(25 pts) A message signal m(t) with bandwidth W is to be transmitted
through a communication channel of bandwidth B.
a. Compute and compare the channel signal-to-noise ratios (SNRc) of DSB-SC
and FM receivers. Note: Assume a system dependent scaling factor of C=1.
: af tof
1 Re ing 2 Oe Fan {Sat OE
DWN ee
SNe ey 2 AS —S Sua = SNe, Pan
Dw. 1 OS Ran
4
ee b. Assuming A,=1 V, W = 4 kHz, and B=100 kHz, determine and compare the
Fei SNR (SNR.) of DSB-SC and FM receivers which utilizes the whole
bandwidth and with the same carrier amplitude A-.
Note: The expressions of the output SNRs of DSB-SC and FM receivers are
given below:
SNR, _ CAP SNR, BALKFP
00.50 = apy We
7
. op
te ene earned Ey Dy
po , Dea lege ake (Axvetv)
Fon
Br eBrroolrs = 26.0148) a2 (R Hf) arlhe th)
=> kp = 0
ste")
SN io pm > SY Po vsa (ar
3 (s0-193)*
pe
Grp
= Spiro, nse * (468,75)
Lo nebe perfrmmen fic PM forte
= SNe, psyEEE 302 Principles of Communications 7 May 2016
Q4.(25 pts)
a. Plot the spectrum of a Pulse Amplitude Modulation (PAM) wave
produced by the modulating signal
AS
a m(t)= A, cos(2af,t)s
assuming a modulation frequency fz = 0.25 Hz, sampling period T; = 1 s,
and pulse duration T= 0.45 s. +
Sloe COG U0) = lly B S-0G) * QO
AS
~
«
SCP) =z MAU) » LS HEE) CF)
>
. kee Derrnc(h Te sc OFF)
seen :
(Anztv) pam git et) >
OMSK op aber ery
ee mes fee
desiree a Gray
fas
b. Using an {deal reconstruction filter, plot the spectrum of the filter output.
(2_ Compare this result with the output that would be obtained if there were
~~ no aperture effect.
age am LO, apo tm
oats A ontne ahkew* sit 3} my
t je cor Low
rar qos * al (5
agperen offer)