Professional Documents
Culture Documents
Chapter 7: Diffusion: Issues To Address..
Chapter 7: Diffusion: Issues To Address..
ISSUES TO ADDRESS...
How does diffusion occur?
Why is it an important part of processing?
How can the rate of diffusion be predicted for
some simple cases?
How does diffusion depend on structure
and temperature?
Chapter 7 - 1
Diffusion
Diffusion - Mass transport by atomic motion
Mechanisms
Gases & Liquids random (Brownian) motion
Solids vacancy diffusion or interstitial diffusion
Chapter 7 - 2
Diffusion
Interdiffusion: In an alloy, atoms tend to migrate
from regions of high conc. to regions of low conc.
Initially
Chapter 7 - 3
Diffusion
Self-diffusion: In an elemental solid, atoms
also migrate.
Label some atoms
C
A
D
B
C
D
A
B
Chapter 7 - 4
Diffusion Mechanisms
Vacancy Diffusion:
atoms exchange with vacancies
applies to substitutional impurities atoms
rate depends on:
-- number of vacancies
-- activation energy to exchange.
Diffusion Simulation
Simulation of
interdiffusion
across an interface:
Rate of substitutional
diffusion depends on:
-- vacancy concentration
-- frequency of jumping
Chapter 7 - 6
Diffusion Mechanisms
Interstitial diffusion smaller atoms can
diffuse between atoms.
Chapter-opening
photograph,
Chapter 7,
Callister &
Rethwisch 9e.
(Courtesy of
Surface Division,
Midland-Ross.)
Chapter 7 - 8
silicon
2. Heat it.
3. Result: Doped
semiconductor
regions.
silicon
Chapter 7 - 9
Diffusion
How do we quantify the amount or rate of diffusion?
Measured empirically
Make thin film (membrane) of known cross-sectional area
Impose concentration gradient
Measure how fast atoms or molecules diffuse through the membrane
M=
mass
diffused
J slope
time
Chapter 7 - 10
Steady-State Diffusion
Rate of diffusion independent of time
Flux proportional to concentration gradient =
C1 C1
C2
x1
C2
x2
D diffusion coefficient
Chapter 7 - 11
Example (cont).
Solution assuming linear conc. gradient
glove
C1
paint
remover
tb
6D
skin
C2
x1 x2
Data:
Chapter 7 - 13
D Do exp
Qd
RT
Chapter 7 - 14
300
600
1000
10-8
1500
C
in
D (m2/s)
n
Fe Fe i
-
1.0
C in -Fe
C in -Fe
Al
-Fe
0.5
Fe
-
10-20
-Fe
in
Al
i
Fe
10
-14
Ci
n
1.5
Al in Al
Fe in -Fe
Fe in -Fe
1000 K/T
Chapter 7 - 15
Temp = T
ln D
1/T
Chapter 7 - 16
Example (cont.)
Chapter 7 - 18
Chapter 7 - 19
bar
pre-existing conc., Co of copper atoms
Cs
Fig. 7.5,
Callister &
Rethwisch 9e.
B.C.
at t = 0, C = Co for 0 x
at t > 0, C = CS for x = 0 (constant surface conc.)
C = Co for x =
Chapter 7 - 20
Solution:
CS
C(x,t)
Co
Chapter 7 - 21
Chapter 7 - 22
Solution (cont.):
t = 49.5 h
Cx = 0.35 wt%
Co = 0.20 wt%
x = 4 x 10-3 m
Cs = 1.0 wt%
erf(z) = 0.8125
Chapter 7 - 23
Solution (cont.):
We must now determine from Table 7.1 the value of z for which the
error function is 0.8125. An interpolation is necessary as follows
z
erf(z)
0.90
z
0.95
0.7970
0.8125
0.8209
z 0.93
Chapter 7 - 24
Solution (cont.):
To solve for the temperature at
which D has the above value,
we use a rearranged form of
Equation (8.9a);
from Table 8.2, for diffusion of C in FCC Fe
Do = 2.3 x 10-5 m2/s Qd = 148,000 J/mol
T = 1300 K = 1027C
Chapter 7 - 25
Chapter 7 - 26
glove
C1
paint
remover
skin
C2
x1 x2
D = 110 x 10-8 cm2/s
Summary
Diffusion FASTER for...
close-packed structures
materials w/secondary
bonding
materials w/covalent
bonding
Chapter 7 - 28
ANNOUNCEMENTS
Reading:
Core Problems:
Self-help Problems:
Chapter 7 - 29