Professional Documents
Culture Documents
LTH 1922
Typical Data
Properties
Value
Unit
Test method
22
dg/min
ISO 1133
MFI (190 0C /5 Kg )
75
dg/min
ISO 1133
29
ml/10min
ISO 1133
MVR (190 0C /5 Kg )
98
ml/10min
ISO 1133
Density
919
Kg/m3
39
ISO 75
Polymer Properties
Thermal Properties
Heat deflection
temperature at 0.45MPa
(HDT/B)
Vicat softening
temperature at 10N
(VST/A)
Melting Point
82
ISO 306
105
DIN 53765
Enthalpy change
104
j/g
DIN 53765
Stress at yield
MPa
ISO 527/2
Stress at break
MPa
ISO 527/2
Strain at break
400
ISO 527/2
Tensile modulus
Creep modulus (After 1
hour)
Creep modulus (After 1000
hour)
Notched lzod at +23C
175
MPa
ISO 527/2
80
MPa
ISO 899
45
MPa
ISO 899
42
KJ/m2
ISO 180 A
KJ/m2
ISO 180 A
Mechanical properties
86
KJ/m2
ISO 8256/1B
8.4
ISO 8256/1B
Maximum Tension
16
MPa
ISO 8256/1B
Hardness Shore D
ISO 868
45
Applied load
49
ISO 2039-1
16
MPa
ESCR
ISO 2039-1
SABTEC
Method
Additive
Antioxidant
Application
LTH 1922 is specially developed for applications that require a good balance between flow
properties and mechanical properties, e.g. toys, household articles, clamping lids.
General information
LTH 1922 has been manufactured using SABTEC licensed technology.
Packaging
Supplied in pellet form and can be packaged in 25kg bags, 1 ton semi bulk or 17 ton bulk.
Food packaging
The above mentioned grade meets the relevant requirements of plastics directive 2002/72/EC (0608-2002) and its amendments till directive 2008/39EC relating to plastic materials and articles
intended to come into contact with foodstuffs.
Pharmaceutical Application
The above mentioned grade meets the requirements of the European pharmacopeia version 6
section 3.1.5 for pharmaceutical application..
Conveying
Conveying equipment should be designed prevent accumulation of fines and dust particles can,
under certain conditions, pose an explosion hazard. We recommend that the conveying system
used:
1. be equipped with adequate filters
2. is operated and maintained in such a manner to ensure no leaks develop
3. that adequate grounding exists at all times
We further recommended that good housekeeping will practiced throughout the facility
Storage
As ultraviolet light may cause a change in the material, all resins should be protected from direct
sunlight and/or heat during storage. The storage location should also be dry, dust Free and the
ambient temperature should not exceed 50 0C. It is also advisable to process polyethylene resins
(in pelletized or powder from) within 6 months after delivery, this because also excessive aging of
polyethylene can lead to a deterioration in quality
Handling
Minimal protection to prevent possible mechanical or thermal injury to the eyes. Fabrication areas
should be ventilated to carry away fumes or vapors.
Combustibility
Polyethylene resins will burn when supplied adequate heat and oxygen. They should be handled
and stored away from contact with direct flames and/or other ignition sources .in burning;
polyethylene resins contribute high heat and may generate a dense black smoke. Fires can be
extinguished by conventional means with water and mist preferred. In enclosed areas, fire fighters
should be provided with self contained breathing apparatus.