Professional Documents
Culture Documents
0
Copyright c 2008 VIVOTEK INC. All rights reserved.
English
Warning Before Install
Power off the Network Camera Keep the Network Camera away
as soon as it is found smoking or from water. If the Network Camera
smelt unusual. is wet, power off immediately.
Contact your distributor when such Contact your distributor when such
cases happen. cases happen.
Do not place the Network Camera Refer to your user's manual for the
around the heat sources, such as operating temperature.
television or oven.
Keep the Network Camera away Do not place the Network Camera
from direct sunlight. in high humid environments.
EN - 1
Do not place the Network Camera Do not touch the Network Camera
on unsteady surfaces. when it's lightening.
EN - 2
English
1 Package Contents
EN - 3
2 Physical Description
Front panel
Status LED
Back panel
External/Internal
MIC switch
Lens
Focus controller
Zoom controller
EN - 4
English
3 Mounting the Lens to the Camera
1. Mount the lens by turning it clockwise onto the camera mount until it stops. If
necessary, turn the lens counterclockwise slowly until it gets the best attitude.
2. Connect the lens cable plug to the camera connector.
For further setup, please refer to the lens' instruction manual inside the
lens package.
4 Network Deployment
2
1
Ethernet switch
POWER LINK
COLLISION RECEIVE
1 2 PARTITION
3 4 5
EN - 5
Power over Ethernet (PoE)
When using a PoE-enabled switch
The camera is PoE-compliant, allowing transmission of power and data via single
Ethernet cable. See the following illustration to connect the camera to a PoE-
enabled switch via Ethernet cable.
POWER LINK
COLLISION RECEIVE
1 2 PARTITION
3 4 5
PoE switch
POWER LINK
COLLISION RECEIVE
1 2 PARTITION
3 4 5
non-PoE switch
EN - 6
English
5 Assigning IP Address
1. Install the "Installation Wizard 2" under the Software Utility directory from software
CD.
2. The program will conduct analyses on your network environment. After your
network is analyzed, please click on the "Next" button to continue the program.
IW2
Installation
Wizard 2
3. The program will search the VIVOTEK Video Receivers, Video Servers or Network
Cameras on the same LAN.
4. After searching, the main installer window will pop up. Click on the MAC that
matches the one labeled on the bottom of your device to connect the Internet
Explorer to the Network Camera.
Network Camera
Model No: IP7251
Mac: 0002D106DB41
0002D106DB41
RoHS
This device complies with part 15 of the FCC rules. Operation is subject to
the following two conditions:
(1)This device may not cause harmful interference, and
(2) this device must accept any interference received, including interference
that may cause undesired operation.
Pat. 6,930,709 Made in Taiwan
EN - 7
6 Ready to Use
Network Camera
For further setup, please refer to user's manual on the software CD.
EN - 8
English
7 Fine-tune the Camera Focus
CS-mount ring
1
3
2
4
EN - 9
P/N:625006300G Ver.1.0
Copyright c 2008 VIVOTEK INC. All rights reserved.