Professional Documents
Culture Documents
Practice Finals
Which address provides an example of an IPv6 link-local address?
FE80::1324:ABCD
2001:2345:AB12:1935::FEFF
2001:1234:0000:9CA::0876/64
1234:ABCD:5678:EF00:9234:AA22:5527:FC35
Top of Form
While configuring a router using RIPng and dual-stack technology with IPv4 and IPv6, the
administrator receives an error message when inputting IPv4 routes. What could cause the error
message?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are shut down
in favor of the newer technology.
Top of Form
Which statement is true about an interface that is configured with the IPv6 address command?
Any IPv4 addresses that are assigned to the interface are replaced with an IPv6 address.
Top of Form
What will be the result of adding the command ip dhcp excluded-address 172.16.4.1 172.16.4.5
to the configuration of a local router that has been configured as a DHCP server?
Traffic that is destined for 172.16.4.1 and 172.16.4.5 will be dropped by the router.
Traffic will not be routed from clients with addresses between 172.16.4.1 and 172.16.4.5.
The DHCP server function of the router will not issue the addresses between 172.16.4.1 and
172.16.4.5.
The router will ignore all traffic that comes from the DHCP servers with addresses
172.16.4.1 and 172.16.4.5.
Top of Form
What does an access control list determine when used with NAT on a Cisco router?
Top of Form
A system administrator must provide Internet connectivity for ten hosts in a small remote office. The ISP has
assigned two public IP addresses to this remote office. How can the system administrator configure the route
provide Internet access to all ten users at the same time?
Top
of
Form
Botto
m of
Form
Top of Form
What three statements describe the roles of devices in a WAN? (Choose three.)
Top of Form
At what physical location does the responsibility for a WAN connection change from the
service provider to the user?
DMZ
local loop
CSU/DSU
demarcation point
Bottom of Form
Refer to the exhibit. Which statement is true about the WAN switch device?
It provides internetworking and WAN access interface ports that are used to
connect to the service provider network.
It provides termination for the digital signal and ensures connection integrity
through error correction and line monitoring.
The WAN link is configured with the Cisco default encapsulation protocol.
Top of Form
Which important piece of troubleshooting information can be discovered about a serial interface
using the show controllers command?
queuing strategy
interface IP address
encapsulation method
Top of Form
Which combination of Layer 2 protocol and authentication should be used to establish a link
between a Cisco and a non-Cisco router without sending authentication information in plain text?
Top of Form
Which three items are LCP options that can be configured for PPP? (Choose three.)
CHAP
Stacker
IPCP
CDPCP
Multilink
Top of Form
At what point in the PPP connection process does the authentication phase occur?
after the link initiator receives a Configure-Ack message from the responder
Bottom of Form
Top of Form
Refer to the exhibit. Why are the routers unable to establish a PPP session?
Interface serial 0/0/0 on Router1 must connect to interface serial 0/0/1 on Router2.
Refer to the exhibit. What would be the result of entering the exhibited
configuration on a Frame Relay router?
Top of Form
Refer to the exhibit. What is placed in the address field in the header of a frame that will travel
from the DC office of ABC Company to the Orlando office?
192.168.1.25
192.168.1.26
DLCI 100
DLCI 200
Top of Form
A company uses a PVC with a committed information rate (CIR) of 128 kb/s and a
committed burst information rate (CBIR) of 64 kb/s. The link is used to periodically send
updates at a rate of 144 kb/s. What will happen to the update traffic?
The traffic will be sent, but the company will be charged a penalty.
The traffic will be sent using the additional CBIR and will be guaranteed delivery.
The traffic will be dropped at the CO for exceeding the committed information rate.
The traffic will be sent, but the burst traffic will be marked for discard if congestion is
encountered.
Bottom of Form
Top of Form
Which two functions are provided by the Local Management Interface (LMI) that is used in
Frame Relay networks? (Choose two.)
flow control
error notification
congestion notification
Refer to the exhibit. You are a network administrator who has been tasked with
completing the Frame Relay topology that interconnects two remote sites. How
should the point-to-point subinterfaces be configured on HQ to complete the
topology?
HQ(config-subif)#frame-relay interface-dlci 103 on Serial 0/0/0.1
HQ(config-subif)#frame-relay interface-dlci 203 on Serial 0/0/0.2
Refer to the exhibit. Branch A has a Cisco router. Branch B has a non-Cisco router
set for IETF encapsulation. After the commands shown are entered, R2 and R3 fail
to establish the PVC. The R2 LMI is Cisco, and the R3 LMI is ANSI. The LMI is
successfully established at both locations. Why is the PVC failing?
The ietf parameter is missing from the frame-relay map ip 10.10.10.3 203
command.
The PVCs at R2 use different encapsulation types. A single port can only
support one encapsulation type.
Top of Form
Refer to the exhibit. A technician is teaching a trainee to interpret the results of various Frame
Relay troubleshooting commands. What conclusion can be drawn from the output that is shown?
Neighboring routers should use DLCI 177 to reach the Branch router.
DLCI 177 will be used to identify all broadcasts that are sent out the Branch router.
The Branch router has the address 192.168.3.1 configured for the S0/0/0 interface.
To reach 192.168.3.1, the Branch router will use the virtual circuit that is identified by DLCI
177.
Top of Form
Refer to the exhibit. Which statement is true about the status of the Frame Relay connection?
Only packets with control bit DE set are sent over the PVC. No data traffic traverses the link.
Packets marked as FECN and BECN indicate that a congestion control mechanism is enabled
on the Frame Relay PVC.
The “DLCI USAGE = LOCAL” status indicates that the PVC link is not established between
the interface S0/0/0.1 and the Frame Relay switch.
Top of Form
Which wireless solution can provide mobile users with non line-of-sight broadband Internet
access at speeds comparable to DSL or cable?
Wi-Fi
WiMAX
satellite
Metro Ethernet
Top of Form
What are two characteristics of DSL technology? (Choose two.)
Uploads typically offer larger transfer rates than downloads.
Service providers deploy DSL in the local loop of the telephone network.
DSL download rates are reduced by large volumes of POTS voice traffic.
Filters and splitters allow POTS and DSL traffic to share the same medium.
DSL is a shared medium that allows many users to share bandwidth available from the
DSLAM.
Refer to the exhibit. A packet is being sent from Host A to Host B through the VPN
tunnel between R1 and R3. When the packet first arrives at R3, what are the source
and destination IP addresses of the packet?
Top of Form
What is a major characteristic of a worm?
malicious software that copies itself into other executable programs
a set of computer instructions that lies dormant until triggered by a specific event
The remote user is not allowed to change the password for that line.
The remote user is prompted to change the line password after connecting to
the router.
Top of Form
What will be the result of the enable secret command when added at the global configuration
mode on the router?
It will use
MD5
encryption to
protect the
privileged
EXEC level
access.
It will use
type 7
encryption
and will
encrypt only
the
privileged
EXEC level
passwords.
It will use
type 7
encryption to
prevent all
passwords
that are
displayed on
the screen
from being
readable.
It will use
MD5
encryption to
protect the
passwords
that are only
used in the
PAP and
CHAP
authenticatio
n process.
Refer to the exhibit. A network administrator is trying to backup the IOS
software on R1 to the TFTP server. He receives the error message that is
shown in the exhibit, and cannot ping the TFTP server from R1. What
action can help to isolate this problem?
Verify that the TFTP server software supports binary file transfers.
Make sure that the TFTP server has 192.168.1.1 as its default
gateway.
Establish an FTP session through an SSH connection for the image download.
Use the Xmodem protocol to download the image through a console connection.
Refer to the exhibit. The network administrator creates a standard access control
list to prohibit traffic from the 192.168.1.0/24 network from reaching the
192.168.2.0/24 network while still permitting Internet access for all networks. On
which router interface and in which direction should it be applied?
Top of Form
What effect would the Router1(config-ext-nacl)# permit tcp 172.16.4.0 0.0.0.255 any eq www
command have when implemented inbound on the f0/0 interface?
Top of Form
Refer to the exhibit. Which two statements correctly describe how Router1 processes an FTP
request that enters interface S0/0/0 and is destined for an FTP server at IP address 192.168.1.5?
(Choose two.)
The router matches the incoming packet to the statement that is created from the access-list
201 permit ip any any command.
The router matches the incoming packet to the statement that is created from the access-list
101 permit ip any 192.168.1.0 0.0.0.255 command.
The router matches the incoming packet to the statement that is created from the access-list
201 deny icmp 192.168.1.0 0.0.0.255 any command.
The packet is allowed into Router1.
Top of Form
Refer to the exhibit. An ACL numbered 101 already exists on this router. What happens if the network
administrator issues the commands that are shown in the exhibit?
A second ACL that is numbered 101 is created and contains only the new commands.
Bottom of Form
Top of Form
Refer to the exhibit. What is the effect of the extended ACL when applied inbound on the S0/0/0
interface on R2?
All IP traffic will be permitted during the specified days and time range.
Both IP and Telnet traffic will be permitted during the specified days and time range.
Only Telnet traffic destined for 172.16.10.0/24 will be permitted during the specified days
and time range.
Telnet traffic will be permitted only during the specified days and time range. All other
network traffic will be permitted any time.
Top of Form
Which wildcard mask would specify all IP addresses from 192.168.8.0 through 192.168.15.255?
0.0.0.7
0.0.7.255
0.0.8.255
0.0.15.255
0.0.255.255
Refer to the exhibit. The SSH connections between the remote user and the server
are failing. The correct configuration of NAT has been verified. What is the most
likely cause of the problem?
Top of Form
A network administrator added two switches and a new VLAN over the past weekend. How can
the administrator determine if the additions and changes improved performance and availability
on the company intranet?
Perform a baseline test and compare the current values to values that were obtained in
previous weeks.
Interview departmental secretaries and determine if they think load time for web pages is
improved.
Compare the hit counts on the company web server for the current week to the values that
were recorded from previous weeks.
Performance on the intranet can be determined by monitoring load times of company web
pages from remote sites.
Top of Form
A company has its headquarters office in Dallas and five branch offices located in New York,
Chicago, Los Angeles, Seattle, and Atlanta. WAN links are used for communications among
offices in six sites. In planning the WAN links, the network designer is given two requirements:
(1) minimize cost and (2) provide a certain level of WAN link reliability with redundant links.
Which topology should the network designer recommend?
star
full mesh
hierarchical
partial mesh
Refer to the exhibit. Router1 and Router2 each support separate areas of a data
center, and are connected via a crossover cable. Resources attached to Router1 are
unable to connect to resources attached to Router2. What is the likely cause?
Top of Form
An administrator is unable to receive e-mail. While troubleshooting the problem, the
administrator is able to ping the local mail server IP address successfully from a remote network
and can successfully resolve the mail server name to an IP address via the use of the nslookup
command. At what layer of the OSI model is the problem most likely to be found?
application
transport
network
data link
Top of Form
Refer to the exhibit. A network technician has been called in to resolve a problem with this
network segment. The symptoms include a loss of connectivity throughout the network segment,
high link utilization, and syslog messages that indicate constant MAC address relearning. What
is the likely cause of these symptoms?
cable fault
IP addressing error
spanning tree problem
Top of Form
Refer to the exhibit. The corporate network that is shown has been assigned network 172.16.128.0/19 for use
branch office LANs. VLSM is not being used. Which subnet mask will allow the most efficient utilization of
addresses?
/21
/22
/23
/24
/25
/26
Bottom of Form
Top of Form
Refer to the exhibit. Which VLAN will carry untagged traffic on FastEthernet 0/1?
VLAN 1
VLAN 2
VLAN 11
VLAN 12
VLAN 30
VLAN 999
Bottom of Form
Refer to the exhibit. In the partial router configuration that is shown, what is the
purpose of access list BLOCK_XYZ?
to block access by Fa0/0 LAN hosts to all network services beyond the router
to prevent users on the Fa0/0 LAN from opening Telnet sessions on the router
to secure Fa0/0 hosts by allowing only locally sourced traffic into the Fa0/0 LAN
Top of Form
Refer to the exhibit. Routers R1 and R2 are both configured for single area OSPF. Users who are
connected to switch S1 are unable to access database applications that run on servers that are
connected to S2. The network engineer is working remotely and only has the information that is
shown in the exhibit to direct initial troubleshooting efforts. Based on the exhibit, which OSI
layer is the most appropriate to start with for a divide-and-conquer approach?
network layer
application layer
data-link layer
physical layer
Refer to the exhibit. An administrator has added the exhibited commands to
routers A and B, but no routing updates are exchanged between the two routers.
Based on the information that is given, what is the likely cause of the problem?
The serial interfaces of routers A and B are not on the same network.
The authentication key numbers do not match the EIGRP process number for
both routers.
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form
Bottom of Form