3210 Always shows charging : reflow or replace CCONT 3310 Signal is normal,but no TX : Reflow/Replace CCONT,COBBA, check Antenna Switch 3310 No response to charger : Check fuse F200 3310 No Signal : hagar, c508, L511(remove it) , PA 3310 Signal OK when first turned on then dissapears : Replace PA, reflow cobba,ccont,hagar 3310 Battery OK until call then low : : Reflow/Replace CCONT, Replace PA 3310 Keys mixed up : Replace R414 and / or R415 (each 2 x 1k) 3310 Will not power up after turned off unless batt removed and replaced : replace / reflow CCONT 3310 Will charge OK but will not power ON : reflow/replace CCONT or check V202 3310 "Insert Sim": : If its is not a SIM-connector problem then usually reflow / replace CCONT 3310 Standby 1 day or less : PA 3310 Intermittent reboots or turns off: Remove L511 3310 LCD displays lines or alternate lines missing etc: Resolder C409 & C410,if no display replace c409,c410,c412,c413 3510 can't charge : Try to change UEM 5210 no speaker : COBBA problem 7210 no ringer : reset phone settings 7650 no ring sound : change ringer 8210 Signal OK but No TX: Reflow Cobba, Reflow Hagar, replace Antenna Switch, replace PA 8210 Signal OK when first turned on then dissapears: : Replace Antenna switch,reball COBBA,B 100 crystal 8210 No signal unless IR active: Change C153 8210 Vibe and Light stay on: Replace User-Iterface IC (adjacent to power switch) 8210 "Not Charging" : rebal/replace CCONT,charging IC or remove V100, near F101 8210 CONTACT SERVICE : COBBA problem(rabal/replace),try to flash phone 8210 No response to charger: Check F101 8210 Will charge OK but will not power ON: : reflow/replace CCONT,or V116 8210, 8250 Locks-up, freezes: Update software, Reflow MAD (Caution, Toxic glue!) 8210/8250 show charging but no charging : check CCONT,line from c!=% near chaps to +,change N401 8210 showing charging without charger : Check CCONT and CHAPS (Charge IC) 6210, 3310 etc Int' drops network: replace Ant' switch, reflow COBBA 6210, 3310 etc Int' drops network and rintones slow: : Replace 32khz crystal 8310, 6510 No response to charger: Check Fuse F100 8310, 6510 One or some keys not working: Replace Z301 8310, 6510 no ring tone : When phone software is old,flash phone with new version of software 8890 no signal after flash : update faid and unlock BEST REGARDS TO ALL