CAUTION! USE OF DEVICE MAY CAUSE MINOR "PIN PRICK" BURNS IF NOT
PROPERLY USED. THESE ARE BY NO MEANS DANGEROUS OR INJURIOUS HOWEVER
MAY CAUSE A SURPRISED REFLEX ACTION
MAGIC MAN REV 2/93
Your Magic Glo battery powered energizer is intended tor magic tricks,
amusements, bar room, gags and party entertainment. It allows you to
energize ordinary household fluorescent or neon lamps without any
electrical wiring, simply by a touch of your hand. Our special beer
mug, stirring rod and other gas filled objects as described can be
activated creating an excellent conversation piece
sINSTRUCTIONS
1. Unpack and check for damage. Contact factory if any is found.
2. Remove rear cap and insert 8 fresh Alkaline 1-1/2 AA batteries
into 8 cell holder. Make sure switch is off if it is a “push on"
“push off" type.
*3. Unwrap antenna lead and connect to earth ground or a large
metallic object. (The socket plate screw on most AC receptacles is a
good ground). (See Special Note).
4. Grab hold of a 2 to 4 foot standard fluorescent tube with one
hand.
5. Grab hold of the Bat Magic with the other hand and press push
button switch. Note fluorescent lamp igniting as held in above step.
Any gas discharge device now will ignite and glow mysteriously as if
you were electrified. The effect will vary with position of the
display tube in reference to ground, large conductive objects or even
people. Experimentation is suggested for optimizing results.
SPECIAL NOTE
*THE ANTENNA LEAD MAY BE HELD BY AN ACCOMPLICE. CAUTION - MAKE A
POSITIVE CONTACT WITH BARE END OF LEAD TO PREVENT ANY PIN PRICK BURNS
THE DISPLAY NOW WILL APPEAR TO ENERGIZE WHEN BOUGHT NEAR THE CONTACTED
ACCOMPLICE.The Magic Glo may also be worn on the person with the foil (handle)
section contacting the skin surface. Caution as improper or loose
contact can cause annoying pin prick burns. (Leg contact will require
a remote switch for control). The antenna lead may now be grounded or
contacted to an accomplice experiment for best results
BRIEF EXPLANATION OF OPSRATION
Your unit transmits low energy harmless radio waves having the
property to ionize the gas in most small lighting displays. Like all
electrical currents a complete circuit is required for optimum effect.
The Magic Glo utilizes high frequency electricity that can flow thru
and between conductive objects. This effect is similar to a capacitor
that is nothing more than two conductive plates separated by a space
of air.
When you touch the foil handle of the unit, current flows thru your
body via the surface of your skin. When you hold the display lamp,
current now wants to flow thru it via the glass walls, end pins etc.
The lamp now becomes part of the plate of our capacitor separated by
the distance between it's body and any grounded object that now acts
as as the other plate. A capacitor is now formed and current flows.
This capacity is approximately 9 pico farads per square meter
separated by one meter (permittivity of space). High frequency
current now flows thru the "capacitor" completing the circuit and
causing the display to glow!
EXPERIMENTATION IS SUGGESTED TO OBTAIN THE BEST RESULTS FOR A GIVEN
DEMONSTRATION. ANTENNA CONNECTIONS, LOCATIONS, PROXIMITY AND DISPLAYS
WILL ALL PLAY A ROLE IN PERFORMANCE.
For those requiring a far more powerful and spectacular effect may
wish to consider our Model #NEONX2100 Power Module. This unit
produces wireless effects over distances of many times more than the
BATGLO. IT MUST BE USED WETH CAUTION AS UNIT CAN PRODUCE MODERATELY
ANNOYING BURNS IF IMPROPERLY CONTACTED.
ORDER #NEONX2100/115