Professional Documents
Culture Documents
05 07 Nissan Frontier Grille Installation Manual
05 07 Nissan Frontier Grille Installation Manual
IMPORTANT! The edges of the “Q” & Mesh grilles can be extremely
sharp. Please handle with care.
Lower Grille Installation Tip: Using a
thumb wheel socket wrench and an 11/32”
socket will make this job much easier. Lower
fastener access is extremely limited.
1
3
1. Use a flat blade screwdriver to remove the factory 2. Open the hood use a long flat blade screw driver 3. The lower mounting clips that retain the bottom
push pins across the top of the grille. to rotate the exposed mounting clips that retain of the grille can be released by sqeezing the clip
the upper grille. Turn them approx. 1/8 of a turn and pulling straight out. Remove all clips from the
and the clips will release. radiator support panel.
6 6
8
5. Peel the protective cover from the stainless steel
grille sections and remove the glue residue using 7. For lower grille installation, you must first remove
solvent and glass cleaner. Align the stainless steel the screws the hold the front tag bracket in place
grille sections into the factory grille openings. and remove the bracket (if equipped).
6. Install the mounting brackets over the studs as 8. Apply masking tape around the lower grille open
4. Install the supplied black silicone sleeves to the shown. Install 8-32 ESNA lock nuts and tighten ing to protect the paint while aligning the lower
mounting studs (trim the ends off with cutters or until snug. DO NOT OVERTIGHTEN OR YOU grille (Pathfinder shown, Frontier similar).
a razor blade). COULD DENT THE GRILLE!
Copyright © 2005 by E&G Classics, Inc.
9
11 12
10. Cut out and align the proper lower grille mounting
hole template into the lower grille opening ends.
Use an awl or similar pointed tool to mark the cen
9. Frontier LE Lower: Apply masking tape to the ter of the mounting hole onto the plastic. 12. Frontier LE Lower: Install a trimmed vinyl cap and
ends of the lower grille opening and paint the 11. Use a 1/4” drill bit to drill completely through the the supplied 5/16” tall PVC spacer onto each stud.
recessed part semi-gloss black as shown. bumper cover (Pathfinder and for lower grille stud Paint the spacer semi-gloss black to conceal it
access. once the grille is installed.
14
13
13 13 15
14 14 16