Professional Documents
Culture Documents
05 Up Chevy Corvette Mesh Grille Installtion Manual
05 Up Chevy Corvette Mesh Grille Installtion Manual
Part #1187-0102-06
Quantity Description Part No.
1 Front Fine Mesh Section 1187-0020-06
1 Rear Mesh (includes): ************
Stainless Steel Mesh Section 1187-0122-06
14 Gage Stainless Steel Surround 1187-0123-06
22 Gage Stainless Steel Overlay 1187-0124-06
1 Hardware Kit (components listed below) 1187-1902-06
6 #8 x 1/2” Black Truss Head Screws 3999-9035-00
5 .130” x 5” Black Nylon Cable Ties 1999-0301-00
3
WILL NOT FIT Z06 MODELS 1
***** IMPORTANT! ***** 1. Raise the back of the vehicle to a comfortable working 3. Pass the rear mesh assembly over the rear exhaust tips
The exposed edges of the stainless height and use jack stands to support the vehicle. NEVER and align it into place in the center of the rear air diffuser.
steel grille and mesh can be work on any vehicle supported by only a jack. Once properly aligned, drill a pilot hole (1/16” or 3/32”
2. Make sure the rear air diffuser is clean before you begin drill bit) and install a black #8 x 1/2” truss head screw
extremely sharp. Please handle the installation. Peel off the protective liner from the rear (one each side) through the rear mesh assembly lower
with care. mesh assembly and clean off the glue residue. brackets.
5, 6
4. Push the top of the rear mesh assembly until it is tight 5. Align the mesh section into the front air intake, making 6. Install a black nylon cable tie at each of the five (5) thin
against the air diffuser. Use a cordless drill with a long sure that the mesh is tight against the five (5) thin black black verticle stiffeners to secure the mesh section. You
phillips bit to reach between the exhaust tips and through verticle stiffeners. can access the back of the air intake by reaching up from
the holes in the rear mesh assembly upper mounting underneath the bottom of the front bumper cover.
flange (4 places), allowing the screws to self tap into the
plastic. Do not overtighten or you will strip out the holes!
6,7
WARRANTY INFORMATION:
8
7 E&G Classics, Inc. warrants its chrome parts and products to be free from
defects in material, workmanship or finish for Thirty-Six (36) months from the date
of shipment by E&G. This warranty is limited to the repair or replacement, at E&G
Classics option, of the defective part or product.
10 You are responsible for inspecting all packages containing E&G Classics' parts
and product immediately upon their receipt and must file a claim with the carri-
er for any damage disclosure by such inspection and notify E&G classics in writ-
ing at the above address of any such damage. This warranty does not extend to
any of our products which have been subject to misuse, neglect, accident or have
been altered or repaired in any way. This warranty does not cover any acciden-
tal or consequential damages for any breach of this warranty agreement. E&G
Classics shall have no responsibility for any loss of time, inconvenience, commer-
cial loss or consequential damage, nor shall E&G be liable for any injury or dam-
age to persons or property by reason of any defect in material, workmanship or
finish of its parts or products. This warranty gives you specific legal rights and
you may also have other rights which may vary from state to state.