Professional Documents
Culture Documents
2. Which three guidelines would help contribute to creating a strong password policy?
(Choose three.)
Write passwords in locations that can be easily retrieved to avoid being locked out.
Use long words found in the dictionary to make passwords that are easy to remember.
3.
Refer to the exhibit. Every time the administrator reboots this router, the boot process
ends in setup mode. What is a possible problem?
The bootstrap version and the version of the IOS are different.
4. Which option correctly defines the capacity through the local loop guaranteed to a
customer by the service provider?
BE
DE
CIR
CBIR
5.
Refer to the exhibit. A host connected to Fa0/0 is unable to acquire an IP address from
the DHCP server. The output of the debug ip dhcp server command shows “DHCPD:
there is no address pool for 10.1.1.1″. What is the problem?
6. Which data link layer encapsulation protocol is used by default for serial connections
between two Cisco routers?
ATM
Frame Relay
HDLC
PPP
SDLC
7.
Refer to the exhibit. Which statement correctly describes how Router1 processes an FTP
request that enters interface s0/0/0 and is destined for an FTP server at IP address
192.168.1.5?
The router matches the incoming packet to the statement that was created by the access-list
201 deny icmp 192.168.1.0 0.0.0.255 any command, continues comparing the packet to the
remaining statements in ACL 201 to ensure that no subsequent statements allow FTP, and
then the router drops the packet.
The router reaches the end of ACL 101 without matching a condition and drops the packet
because there is no statement that was created by the access-list 101 permit ip any any
command.
The router matches the incoming packet to the statement that was created by the access-list
101 permit ip any 192.168.1.0 0.0.0.255 command and allows the packet into the router.
It matches the incoming packet to the statement that was created by the access-list 201
permit ip any any command and allows the packet into the router.
8. Compared with IDS systems, what can IPS systems do to provide further protection
of computer systems?
9. Which IEEE 802.16 broadband wireless technology allows users to connect to the ISP
at speeds comparable to DSL and cable?
Wi-Fi
satellite
WiMAX
Metro Ethernet
10. A network administrator has changed the VLAN configurations on his network
switches over the past weekend. How can the administrator determine if the additions
and changes improved performance and availability on the company intranet?
Conduct a performance test and compare with the baseline that was established previously.
Interview departmental secretaries and determine if they think load time for web pages has
improved.
Determine performance on the intranet by monitoring load times of company web pages from
remote sites.
Compare the hit counts on the company web server for the current week to the values that
were recorded in previous weeks.
11.
Refer to the exhibit. What is the meaning of the term dynamic in the output of the
command?
The bandwidth capability of the interface increases and decreases automatically based on
BECNs.
DLCI 100 will automatically adapt to changes in the Frame Relay cloud.
12. Which type of ACL will permit traffic inbound into a private network only if an
outbound session has already been established between the source and destination?
extended
reflexive
standard
time-based
13. Which two statements are true about IPv6 link local addresses? (Choose two.)
14. A company is looking for a WAN solution to connect its headquarters site to four
remote sites. What are two advantages that dedicated leased lines provide compared to a
shared Frame Relay solution? (Choose two.)
reduced jitter
reduced costs
reduced latency
the ability to borrow unused bandwidth from the leased lines of other customers
15.
a successful connection but inability to make configuration changes because of the absence of
an enable secret password
16. What are two effective measures for securing routers? (Choose two.)
17. An issue of response time has recently arisen on an application server. The new
release of a software package has also been installed on the server. The configuration of
the network has changed recently. To identify the problem, individuals from both teams
responsible for the recent changes begin to investigate the source of the problem. Which
statement applies to this situation?
Scheduling will be easy if the network and software teams work independently.
It will be difficult to isolate the problem if two teams are implementing changes
independently.
Results from changes will be easier to reconcile and document if each team works in
isolation.
Only results from the software package should be tested as the network is designed to
accommodate the proposed software platform.
18.
Refer to the exhibit. From the output of the show interfaces and ping commands, at
which layer of the OSI model is a fault indicated?
application
transport
network
data link
physical
19. Which technology is used to dynamically map next hop, network layer addresses to
virtual circuits in a Frame Relay network?
Inverse ARP
LMI
DLCI
FECN
20. An administrator learns of an e-mail that has been received by a number of users in
the company. This e-mail appears to come from the office of the administrator. The e-
mail asks the users to confirm their account and password information. Which type of
security threat does this e-mail represent?
cracking
phishing
phreaking
spamming
21.
TDM
PPP
HDLC
SLIP
22.
Refer to the exhibit. Results of the show vlan and show vtp status commands for
switches S1 and S2 are displayed in the exhibit. VLAN 11 was created on S1. Why is
VLAN 11 missing from S2?
application layer
network layer
physical layer
25. Where does a service provider assume responsibility from a customer for a WAN
connection?
local loop
demarcation point
demilitarized zone
26. What will be the result of adding the command ip dhcp excluded-address
192.168.24.1 192.168.24.5 to the configuration of a local router that has been configured as a
DHCP server?
Traffic that is destined for 192.168.24.1 and 192.168.24.5 will be dropped by the router.
Traffic will not be routed from clients with addresses between 192.168.24.1 and 192.168.24.5.
The DHCP server will not issue the addresses ranging from 192.168.24.1 to 192.168.24.5.
The router will ignore all traffic that comes from the DHCP servers with addresses
192.168.24.1 and 192.168.24.5.
27.
Refer to the exhibit. Partial results of the show access-lists and show ip interface
FastEthernet 0/1 commands for router Router1 are shown. There are no other ACLs in
effect. Host A is unable to telnet to host B. Which action will correct the problem but
still restrict other traffic between the two networks?
Modify the second entry in the list to permit tcp host 172.16.10.10 any eq telnet .
28.
Refer to the exhibit. The corporate network that is shown has been assigned network
172.16.128.0/19 for use at branch office LANs. If VLSM is used, what mask should be
used for addressing hosts at Branch4 with minimal waste from unused addresses?
/19
/20
/21
/22
/23
/24
29.
Refer to the exhibit. RIPv2 has been configured on all routers in the network. Routers
R1 and R3 have not received any RIP routing updates. What will fix the issue?
Enable CDP on R2 so that the other routers will receive routing updates.
30.
Refer to the exhibit. This serial interface is not functioning correctly. Based on the
output shown, what is the most likely cause?
unplugged cable
31. Which statement is true about PAP in the authentication of a PPP session?
32. An administrator is configuring a dual stack router with IPv6 and IPv4 using RIPng.
The administrator receives an error message when trying to enter the IPv4 routes into
RIPng. What is the cause of the problem?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are over-written
in favor of the newer technology.
using alternate paths to avoid access control lists and bypass security measures
encapsulating an entire packet within another packet for transmission over a network
NCP tests the link to ensure that the link quality is sufficient.
35.
Refer to the exhibit. A network administrator is creating a prototype to verify the new
WAN design. However, the communication between the two routers cannot be
established. Based on the output of the commands, what can be done to solve the
problem?
36.
Refer to the exhibit. Based on the output as shown, which two statements correctly
define how the router will treat Telnet traffic that comes into interface FastEthernet
0/1? (Choose two).
37. Which Frame Relay flow control mechanism is used to signal routers that they
should reduce the flow rate of frames?
DE
BE
CIR
FECN
CBIR
38.
Refer to the exhibit. A network administrator configures a standard access control list
on Router1 to prohibit traffic from the 192.168.0.0/24 network from reaching the
Internet. The access control list also permits traffic from the 192.168.0.0/24 network to
reach the 192.168.1.0/24 network. On which interface and in which direction should the
access control list be applied?
interface Fa0/0, inbound
39. Which configuration on the vty lines provides the best security measure for network
administrators to remotely access the core routers at headquarters?
40.
Refer to the exhibit. What can be concluded from the exhibited output of the debug ip
nat command?
Extended ACLs should be applied closest to the source that is specified by the ACL.
42.
Refer to the exhibit. Headquarters is connected through the Internet to branch office A
and branch office B. Which WAN technology would be best suited to provide secure
connectivity between headquarters and both branch offices?
ATM
VPN
ISDN
Frame Relay
broadband DSL
43. Which three physical network problems should be checked when a bottom-up
troubleshooting approach has been chosen to troubleshoot network performance?
(Choose three.)
cable connectivity
44.
The frame-relay map commands are missing the cisco keyword at the end.
A single router interface cannot connect to more than one Frame Relay peer at a time.
45. Which IP address and wildcard mask would be used in an ACL to block traffic from
all hosts on the same subnet as host 192.168.16.43/28?
47. When would the multipoint keyword be used in Frame Relay PVCs configuration?
48. A network technician analyzes the network and notices late collisions. The collisions
occur accompanied by jabber that originates from the server. What is the likely cause of
the problem?
49.
Refer to the exhibit. R1 is performing NAT overload for the 10.1.1.0/24 inside network.
Host A has sent a packet to the web server. What is the destination IP address of the
return packet from the web server?
10.1.1.2:1234
172.30.20.1:1234
172.30.20.1:3333
192.168.1.2:80
50.
Refer to the exhibit. All devices are configured as shown in the exhibit. PC1 is unable to
ping the default gateway. What is the cause of the problem?
51. When Frame Relay encapsulation is used, what feature provides flow control and
exchanges information about the status of virtual circuits?
LCP
LMI
DLCI
Inverse ARP
52. A network administrator is tasked with maintaining two remote locations in the
same city. Both locations use the same service provider and have the same service plan
for DSL service. When comparing download rates, it is noticed that the location on the
East side of town has a faster download rate than the location on the West side of town.
How can this be explained?