Professional Documents
Culture Documents
Industry Standard CAT
Industry Standard CAT
The images below depict the cable pin-outs for straight-through and cross-over Cat-5 Ethernet
cables that conform to EIA/TIA industry standard for 568 A and B. IF the first and second pin
are orange, the cable is 568B. If the first and second pins are green, the cable is 568A. If one end
of the cable is A and the other end is B then you now have a cross-over.
• No connectivity
• Radio not negotiating correctly
• Needing to be set to 10 Half Duplex (HDX) or 10 Full Duplex (FDX)
• Connectivity to the radio only at a very short distance
Pin Functionalities
1 Data (TX +)
2 Data (TX -)
3 Data (RX +)
4 Ground (-)
5 Ground (-)
6 Data (RX -)
7 Power (+)
8 Power (+)
1. Use the programming cable (CBLDAT-1) supplied with your Access5800 or Access5830
AP and TrangoLINK-10 to connect to the RJ11 port of the radio to the serial port of the
PC.
2. Run a terminal emulation program, such as HyperTerminal™
3. Set the communication parameters as shown in the following table:
Parameter Value
Baud Rate 9600
Data Bits 8
Stop Bits 1
Parity None
Flow Control none
•