72
73
DEP 31.40.21.30-Gen.
December 1995
Replace Table 1 with the following:
Table 1 Chemical requirements for product analyses
Element | Maximum Permitted Alloy Notes
Content, wi
c 0.18
Mn 1.60 (1.30) 1
Si 0.45,
P 0.025 (0.020) 1
s 0.010 (0.003) 1
v 0.08: 2
Nb 0.05 2
Ti 04 2
cr 0.20 3
Mo 010 3
Ni 0.35 3
cu 0.40 3
Al 0.05, 4
N o.o12 4
B 0.0005
ca (0.006) 5
CE 045 S
Pom 0.23 7
Notes: 1. Maximumlevels or sow serve fitings ae given in brackets
2. VrNoeTr hall not excoed 0.5%,
4. CreMorheeCu shal nat exceed 0 64%
‘4 Tho total AN ratio sil ot be ls than 21
5. Galeum adcions are not necessary satisfactory HC test performance is achieves
8 CES C+ Mri + (Cross + (NieCuyts
5. Bem=C+ S180 + (in = Cu 467720» NBD + Mo/1S + VII + 5
Replace this section withthe following:
For all grades, analysis for all elements in the Table shall be performed.
‘Amend this section as follows:
‘The carbon equivalent shall not exceed 0.45,
Page 11,