Series $340
1000-4000 Amp
Single-Coil Contactor
Nema 3R & 12 Enclosures
Automatic Transfer Switch
Non-Automatic Transfer Switch
'4)
Operation and
Installation
Manual
KOHLER
Transfer Switches
‘kohler Company, 1964. ll Rights Reserve.CONTENTS
Safety Precautions
Introduction
Function
Ratings .-
Installation
Unpacking
‘Mounting
Line Connections......
Auxiliary Connections
Functional Test...
Manual Operation
Electrical Operation...
General Maintenance ....
‘Troubleshooting...
Sequence of Operation
Accessories .
Manual Controls
Generator Set Exercising Timer
Motor Load Transfer ......
Disconnecting the Contro! Panel.
Sensor Adjustments ...-.....+
Time Delay Adjustments
Wiring Diagrams .
Cutline anc Mounting Diagrams
toe
‘Switch No, —____
Serial No.SAFETY PRECAUTIONS.
Read these safety instructions earetuly. Falure to
fellow instructions and safety rules cou result in
‘Seraus bodly injury andlor damage fo the Wwanstor
Switch or test equipment
Awannina.
HIGH VOLTAGE! Rememberthatwnerever
lactic energy is present, tere is the
potential danger of elecvocution. Keep
Everyone away trom the stand take pre-
Enutions to prevent unqualified personne!
ftomtampering. Havetnesetandetectcal
Crreuits services only by qualfed the
ficians. Winng should be Inspected fre-
(quently replace leeds thatarerayesarin
oor conaian. De net operate lectcal
Eaulprent nen standing in water,on wet
{'0und, or when your han are wet,
Awannine
BODILY INJURY! A detachable operator
handles provides onthe Trenstor Such
formaintenanes purposes only. Return the
{ranstor Swen ta the Normal postion
Remove manual operatornandleandetore
Ieean the Tranoer Svrteh inthe place
Provided when sence is compete.
Awanninc
SHOCK HAZARD! The Teanser Switch
wil now be energized. Proceed with cael
warning.
SHOCK HAZARDIDe-enerai2ethe normal
Source branen to. be connected to the
“ranstor Switch Betore making sry line OF
AUxiiary connections
AwaRnine
‘SHOCK HAZARD! De-energize both nox
mal and emergency sources belore pro-
{eeding. Mowe Generator Nester Switch
‘on controler OFF postion and cizcon”
PectBattery negative botore working on
‘Tansier switch Turn the transl ston
‘olcter even tothe OFF postion,
Awannins.
ELECTRICAL SHOCK! The Automatic
‘Transter Switchis energized: proceed with
Garat High Voltago can cauzo_ personal
Injury, damageequipment. orld ature
‘allure, Removerings weiches, and jowel-
fyithe can cause short erie. This test
should be done only bya qualified elecr-
ian, Folow manufacturers instructions
who operating tstr.
wanna
‘SHOCK HAZARD! Disconnect inner pane
harness at in-line connector. Th we
Cnersie circu Boars an fogie circuit,
but ‘allow transfer ewiten to continu *0
Supply utlty power te neceesaryighting
ndequpment Polonia elecracuen wil
‘kt any accescorles mounted to inner
panel are NOT wired through and de-
rerelzes by hemess separation Such
‘ceessories maybe at ine voltage.