Professional Documents
Culture Documents
ECE303
ECE303
L: 0
T: 0
P: 4
Cr: 2
Course Planner :-
TextBook
1. Lab Manuals
Other Specific Books
2. 3. 4.
Other Readings
J.S.Katre,Signals and systems, Tech Max Publication, 2008 A. Vallabraj, Digital Signal Processing, Tata McGraw-Hill, 2008 Alan V. Oppenheim,Signals and systems, Pearson Education, 2008
Sr. No.
5 6
A MATLAB-Based Digital Signal Processing Laboratory Course,Sanjit K. Mitra, Department of Electrical & Computer Engineering University of California. ece.ucsb.edu Analysis and Design of Electronic Circuits, Spring 2004
Relevant Websites
Sr. No.
Web adress
Salient Features
7 8 9 10 11
Introduction to MATLAB Matlab toolbox Basics of Matlab Datasheet of 8085 8085 projects
Page 1 of 4
Lab Assesment
10
12
Total :-
10
100
100
* In ENG courses wherever the total exceeds 100, consider x best out of y components of CA, as explained in teacher's guide available on the UMS
*Each experiment of the lab will be evaluated using following relative scheme:
Component
% of Marks
J/E WR VIVA
20 50 30
Page 2 of 4
Before Mid-Term
MATLAB,HW,MPkit,si mulator 1 MATLAB,HW,MPkit,si mulator 2 MATLAB,HW,MPkit,si mulator 3 MATLAB,HW,MPkit,si mulator 4 MATLAB,HW,MPkit,si mulator 5 MATLAB,HW,MPkit,si mulator 6
To develop program for discrete convolution and correlation using MATLAB To develop a program for computing DFT and IDFT in MATLAB. To develop a program for computing circular convolution Using MATLAB To develop a program for computing inverse Z-transform using MATLAB To develop a program for designing FIR filter in MATLAB To design and implement on a breadboard a circuit to perform Amplitude Modulation.
MATLAB Signal Processing Tool Box Two IC BC 107BP,33k, 100k,two 4.7k,270ohm resistor,two 4.7?F capacitor, CRO(20 Mhz),Function generator(1Mhz),connecting wires and probes.
After Mid-Term
MATLAB,HW,MPkit,si mulator 7
IC LM 2206,10k, two 100k,three 4.7k,220ohm resistor,22?F,1?F,10?F,0.01?F, CRO(20 Mhz),Function generator(1Mhz),connecting wires and probes. Stepper motor (12 volts), 12V Power Supply, IC UNL2003 (Driver IC). LEDs, 1K Resistors(10), +5V Power Supply
Interfacing and control of stepper motor using 8085 microprocessor. Generation of delay in binary counting using 8085 microprocessor.
Page 3 of 4
To implement a moving 7-segment display with suitable delay using 8085 microprocessor. Write a program to interface two digit numbers using seven Segment LEDs, use 8086 microprocessor and 8255 PPI.
7-segment display.
7-segment display.
Spill Over
MATLAB,HW,MPkit,si mulator 12
Compile, Elaborate and simulate a 2-to-1 mux design using Incisive Simulator
Incisive Simulator
Page 4 of 4