1996 Oldsmobile Aurora V8-4.

0L VIN C

Copyright ?2009, ALLDATA

10.10

Page 1

Lamp Control Module: Technical Service Bulletins Alarm/Lock/Lighting Module - Replacement Procedures
File In Section: 8 - Chassis/Body Electrical Bulletin No: 53-83-19 Date: October, 1995 SERVICE MANUAL UPDATE Subject: Section 8C - Replacement Procedures for Multi-Function Alarm, Lock and Lighting Module (MALL), Starter Enable Relay and Lamp Control Module Models: 1996 Buick Riviera 1996 Oldsmobile Aurora Please insert the following replacement procedures and illustration in Section 80 of the Service Manual.

Multifunction Alarm, Lock and Lighting Module (MALL) Remove or Disconnect 1. 2. 3. Left lower I/P insulator, (2) screws, (1) light bulb. Electrical connector(s). MALL module from multi-use bracket. Press down on center tab of mounting bracket and slide MALL module downward until mounting rails disengage.

Install or Connect 1. MALL module to multi-use bracket. ^ ^ Align mounting rails on module with mounting bracket rails. Slide module forward into place until locking tab engages.

1996 Oldsmobile Aurora V8-4.0L VIN C 2. 3. Electrical connector(s). Left lower I/P insulator.

Copyright ?2009, ALLDATA

10.10

Page 2

Starter Enable Relay Remove or Disconnect 1. 2. Left lower I/P insulator, (2) screws, (1) light bulb. Electrical connector(s).

Slide starter enable relay from bracket. Install or Connect 1. 2. 3. Slide starter enable relay onto bracket. Electrical connector(s). Left lower I/P insulator.

Lamp Control Module Remove or Disconnect 1. 2. 3. Left lower I/P insulator, (2) screws, (1) light bulb. Electrical connector(s). Lamp control module from multi-use bracket. Press down on center tab of mounting bracket and slide module downward until mounting rails disengage.

Install or Connect 1. Lamp control module to multi-use bracket. ^ ^ 2. 3. Align mounting rails on module with mounting bracket rails. Slide module forward into place until locking tab engages.

Electrical connector(s). Left lower I/P insulator.