Professional Documents
Culture Documents
Werndl Tenaro Orga Wall 60v Assembly Instructions
Werndl Tenaro Orga Wall 60v Assembly Instructions
1.0
Clamping plate
Orga-Panel
Connecting Profile
Vertical Profile
page 1
Orga-Wall 60
2.0
2.1
Insert connection profile into the groove of the vertical orgawall profile. Fixing of profile in requested height position with screws (M4x12). The big hole diam. 6 mm must be at the top position.
Turn screws (DIN 7500, M3x10) into the remaining thread in such a way that the head presides for approx. 4 mm over connection profile
2.2
2.3
Insert clamping plate on the left and right hand side completely into top groove of orgapanel (entry pilot outside)
Put the orgapanel with the bottom groove over the 4 mm presiding screw (A). Afterwards, rotate panel in vertical position.
page 2
Orga-Wall 60
2.4
B
Push clamping plate into the top hole (B) of the connecting profile and fix panel by tightening screws.
Seite 3