You are on page 1of 1

Router#conf t Enter configuration commands, one per line. End with CNTL/Z.

Router(config)#hos Router(config)#hostname R1 R1(config)#int s0/0/1 R1(config-if)#ip add R1(config-if)#ip address 170.20.3.82 % Incomplete command. R1(config-if)#ip address 170.20.3.82 255.255.255.252 R1(config-if)#no sh %LINK-5-CHANGED: Interface Serial0/0/1, changed state to up R1(config-if)#cl R1(config-if)#clock r R1(config-if)#clock rate 56000 R1(config-if)#ba R1(config-if)#bandwidth %LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/1, changed state to up 128000 R1(config-if)#

You might also like