Professional Documents
Culture Documents
SPECIFICATIONS
Model Number PNL220 PNL660 PNL1300 PNL2200 PNL4400 PNL6600 Lift Capacity (lbs.) Plate Round 220 110 660 330 1300 660 2200 1100 4400 2200 6600 3300 Magnet (in.) Length Width 3-5/8 2-5/8 6-3/8 3-5/8 9-1/8 4-7/8 10-5/8 7-1/8 14-7/8 9-1/4 18-1/16 11-1/4 Overall Height (in.) 6-5/8 8-7/8 8-7/8 8-7/8 18 22-1/4 A 3/16 1/2 5/8 3/4 7/8 1-7/16 Bail Opening (in.) B 1-1/2 1-3/4 2-1/4 3-3/4 4-3/4 5-3/4 C 1-3/8 2-3/8 3-1/2 4-3/4 6 7-1/4 Handle Length (in.) 5-7/8 6-7/8 6-3/4 10-1/8 16-3/4 20-5/8 Weight (lbs.) 7 22 53 110 276 485
HOLDING VALUE & MAXIMUM SHEET SIZE FOR SPECIFIED MATERIAL THICKNESS
Model Number PNL220 PNL660 PNL1300 PNL2200 PNL4400 PNL6600 1/4" Cap. Size 180 4 x 4.5 270 4x6 3/8" Cap. Size 220 4 x 3.5 500 4x8 Sheet Thickness - Capacity (lbs.) / Size (ft.) 1/2" 3/4" 1" Cap. Size Cap. Size Cap. Size 220 3 x 3.5 220 2x3 220 2 x 2.5 615 4 x 7.5 660 4x5 660 4x4 655 4x8 1000 4x8 1300 4x8 1300 4x8 2" Cap. 220 660 1300 2200 2625 4084 Size 1 x 2.5 3 x 2.5 4x4 4x7 4x8 5 x 10 Cap. 220 660 1300 2200 4400 6125 3" Size 1 x 1.5 2 x 2.5 4 x 2.5 4 x 4.5 4x8 5 x 10
All capacities are based on lifting clean, smooth, flat low-carbon steel plate with the full area of the magnets lifting surface in contact with the load. Derating is required for plates or other loads with rust or scale. Do not use on material thinner than 1/4".
F.32
NOTE: When lifting 4' x 8' sheets or any sheets over 4' x 8', use 2 or more magnets on a spreader bar to prevent sheet flexing, sagging, or peel-off. Material less than 3/8" thick is susceptible to magnet bleed through, resulting in two sheets lifted at once.