Professional Documents
Culture Documents
Table of Contents
5.
Shift into or [P] position. To store the engine negative pressure in memory, let the engine idle in or position for one minute under the following conditions: With the brake pedal depressed. With the A/C switch OFF. With the combination light switch OFF. With the heater fan switch OFF. Turn OFF all other electrical systems. NOTE: Start step 5 within 60 seconds after the radiator fan goes off.
CAUTION: Do not use this procedure on '97 - 00 models or you will damage the transmission. On '97 - 00 models, the TCM or PCM memorizes the feedback signals when you drive the vehicle. 1.
6.
Shift into position, and let the engine idle for two minutes to store the feedback signal i n memory under the same conditions as in step 5. Connect the Honda PGM Tester. Check that the TCM has completed the start clutch calibration. NOTE: The TCM will not store the feedback signal when the CVT fluid temperature is below 40C (104F) even if the engine coolant temperature reaches the normal operating temperature. Repeat these procedures until the start clutch calibration is completed.
Engage the parking brake, and block the front wheels securely. Connect the SCS service connector to the Service Check Connector as shown. (The Service Check Connector (2P) is located under the dash on the passenger's side of the vehicle.)
7.
2.
8.
Disconnect the SCS service connector from the Service Check Connector.
'97 - 00 Models
The TCM ('97 - 98 models) and PCM ('99 - 00 models) memorize the feedback signal when you drive the vehicle as follows:
3. Start the engine, and warm it up to normal operating temperature (the radiator fan comes on twice). 4.
After warming up the engine (the radiator fan comes on). Shift into [D] position. Turn OFF all electrical systems. Drive the vehicle up to the speed 37 mph (60 km/h). After the speed reaches 37 m p h (60 km/h), release the accelerator for 5 seconds.
Fully depress the brake pedal and accelerator for 20 position. seconds in