Professional Documents
Culture Documents
RFQ For Spare Parts and Services
RFQ For Spare Parts and Services
SCADA HARDWARE AND SOFTWARE A 1 Maintenance service On-Site service for all servers covering parts for 02 years (performed by Authorized Manufacturer's representative ) On-Site service for all workstation covering parts for 02 years (performed by Authorized Manufacturer's representative )
lot
lot
B 1
Spare parts & Tools Spare parts equal to at least 25% of the field replacement components. At minimum, the following shall be provided: One spare Ethernet network interface card of each type used with CD of operating system drivers and utility software One spare Media drive of each type used within the system and CD of operating system drivers and utility software
lot
lot
One spare cable or adapter used between the computer and any of its peripherals 2 Special tools required for normal maintenance Provide a list of all spare and replacement parts with the prices which shall remain in effect for a period of not less than 01 year after start-up and final acceptance
lot lot
1 1
lot
PLC HARDWARE AND SOFTWARE Spare parts & Tools The Contractor provides the recommended spare parts & Tool for PLC's hardware & software based on its experience
lot
INSTRUMENT Handheld programmer where required for configuration and calibration of the instrument
lot
FO CABLING AND EQUIPMENT Test equipment & Tools 1 2 One complete FO connector termination tool kit Single handheld device of Optical power source & test meter lot lot 1 1 The detailed specifications are indicated in the spec.
Spare parts & Test equipment Fuses: 20% of each size & type used but no less than ten of each size and type Relays: 20% of each type used but no less than ten of each type DC power supplies: 20% of each size & type used but no less than two of each size & type Lamps: 20% of each size & type used but no less than ten of each size & type Corrosion inhibiting vapor capsules: Provide 100 of each type & size used
1 2 3 4 5
1 1 1 1 1
Additional notes for PLC control panels: The door of the control panels LTPCP and SHCP shall be modified to accommodate the NEMA 12 IOWs. The workstation shall be flush mounted to the exterior of the door
Total