GULF STANDARD SAUD! STANDARD
No. 584/1995 No. 235/1995
METHODS OF TEST FOR
CLAY PIPES FOR
DRAINING an AND WATER
7
}
Kingdom of Saudi ArabiaStandardization & Metrology Organization
for G.C.C. (GSMO)
P.O. Box - 85245 RIYADH - 11691
METHODS OF TEST FOR
CLAY PIPES FOR
DRAINING SEWAGE AND WATER
UDC 621.643.2 - 3.6:628.2/3
This Standard is issued on the basis of the decision of the Board of
Directors in accordance with the decision of the Supreme Council of the
G.C.C. States in its Third Session, held in Bahrain on 1403-01-23
(corresponding to 1982-11-09).
Date of Board of Directors’ Approval
7-5-1416 Corresponding to 1-10-1995
Date of Publication in the Official Gazette
17-6-1416 Corresponding to 10-11-1995
Date of Enforcement
17-12-1416 Corresponding to 4-5-1996
ISSN : 1319 - 2337
All rights reserved to this organization[~ GULF sTANDARD GS 584/1995
METHODS OF TEST FOR
CLAY PIPES FOR
DRAINING SEWAGE AND WATER
1- SCOPE AND FIELD OF APPLICATION
This standard is concerned with the methods of test for socket and spigot clay pipes for draining sewage
and water under the effect of gravity.
2. APPEARANCE TEST
The surface of the pipe shall be cleaned with a clean piece of cloth and checked with the naked eye to
make sure that it is uniform and having smooth internal surface and edges. It shall be free from visible
defects and cracks, which affect the pipe’s efficiency of performance.
3+ DIMENSIONS MEASUREMENT
3.1 Length
3.1.1 Suitable length measuring instrument with an accuracy of 1 mm shall be used.
3.1.2 The actual length of the pipe (straight length) from inside shall be measured at three different
locations of the cross-section of the pipe and at approximately equal distances (one third of the
circumference) as shown in Fig. (1), and the mean value of the three readings taken.
3.2 Diameter
3.2.1 Suitable length measuring instrument with an accuracy of 0.5 mm shall be used.
3.2.2 The inside diameter of the pipe shall be measured at the two ends of the straight part, with two
‘measurements at right angles taken at each end. The mean value of the measurements shall be
considered as the inside diameter of the pipe.
3.3. Thickness
3.3.1 The thickness shall be measured to the nearest 0.5 mm at several locations on the pipe
circumference. The maximum and minimum values shall be taken and the difference between
them calculated.
4. STRAIGHTNESS TEST
4 Apparatus
4.1.1 Steel straight edge, the length of which is 0.8 from the actual length of the pipe.