Professional Documents
Culture Documents
2. Calculate free space path loss formulae at the transmitting antenna side?
3. Explain omnidirectional antenna configuration?
4. Explain directional antenna configuration ?
5. Explain Space diversity antenna system and its importance?
6. Explain umbrella pattern antenna system?
7. Explain antenna pattern in free space and in mobile radio environment?
3. The coverage area of the antenna increases with ____________ in beam width
(a) increase (b) decrease (c) both
10. _______ receiving antennas are used to receive all 45 radio channels
(a) 2 (b) 1 (c) 4 (d) 3
UNIT 6
4) 21. In a 60degree sector system the cell site is divided into ______ sectors
30. 6 (b) 2 (c) 3 (d) 5
7) If the user moves away from the cell site then its signal strength _____
(a) decrease s (b) increases (c) constant (d) negative slope
8. the process of sharing frequency channel frm one channel to other is called _____
(a) channel sharing (b) channel borrowing (c) channel stoping (d) none
10. The process of borrowing new frequencies frm other cell sites is called _____
(a) channel borrowing (b) channel sharing (c) channel assigning
14.The process of using same frequency number of times in a cell site is called _____
(a) frequency reuse (b) channel splitting (c) assignment
15. The process of changing frequency when the user moves frm one cell to other is
called ______
(a) handoff (b) frequency reuse (c) cell splitting
(a) low voice signal strength (b) no coverage (c) no setup channel
5. If the distance frm cell site increases then signal strength ______
(a) decreases (b) increases (c) constant (d) none
12. __________ hand off occurs between two cell sites softly without change in
frequency
(a) hard handoff (b) soft handoff (c) forced handoff
13. If handoffs are increased then the dropped call rate ________
(a) increases (b) decreases (c) remains same (d) none
LDIC DESCRIPTIVE
5. Explain
OBJECTIVE
1. In weighted resistor type DAC the resistance value _______ with increase in no of bits
(a) increases (b) decreases (c) constant (d0 none
5. The block which assigns code values to quantized values is called _____
(a) encoder (b) quantizer (c0 sampler (d) none