Professional Documents
Culture Documents
Tension&Compression For Steel Members
Tension&Compression For Steel Members
Input the chosen section. Input the given specifications of the chosen section. Input the design specifications of the chosen section. Check for validity. Check if the section chosen is adequate for the given load. DH = AG = AN = BF = TF = RX = RY = Rmin = IX = IY =
NOTE:
DH = AG = TF = RX = RY = Rmin = 25 mm 2 7613 mm 13.08 mm 49.02 mm 130.302 mm 49.02 mm FOR WELDED MEMBERS: P= L= N= FU = FY = 980000 N 9000 mm 4 400 Mpa 248 Mpa for U shape section U= FOR BOLTED OR RIVETED 0.9 ok! 0.85 not ok! 0.75 three or more fasteners per line only two fasteners per line
U=
1 not ok! 0.87 not ok! 0.75 not ok! BOLTED OR RIVETED 0.85 USE U=
2 MIN AG = 6586.02151 mm
WELDED #DIV/0!
mm2
SECTION AN =
6305 mm
WELDED #DIV/0!
DH = AG = TF = IX = IY = = =
Area = RY = RX =
15548 mm 63 mm 65 mm
Rmin, (mm)
63
P= L= FU = FY =
LEGEND
Hole Diameter
Gross Area Net Area Flange Base Flange Thickness Radius of Gyration (x-axis) Radius of Gyration (y-axis) Minimum Radius Moment of Inertia (x-axis) Moment of Inertia (y-axis) P = Axial Load L = Length d = Depth FU = Ultimate Strength FY = Yield Point K = Effectiveness Length Factors E = Modulus of Elasticity Fa = Allowable Axial Stress Lw = Weld Length w = Plate Width
N OF TENSION MEMBERS
for W, M, & S shapes section three or more fasteners per line only two fasteners per line BF = d= 203.327 303.276
4 1.35E+08 mm 4 2.05E+08 mm
SLENDERNESS RATIO: 108.8605 mm RADUIS OF GYRATION: 82.67459 mm LOAD CAPACITY: 1693.344 kN 1718.19 kN
OK!
OK! OK!