Professional Documents
Culture Documents
reboot
licensePort -- show
*** POD license management ***
reserve a port license
licensePort --show
licensePort --reserve 0
disable a port
if all reservations are assigned
portDisable
remove the port from POD license
licensePort --relase 0
releasing a port from a POD set
switchDisable
switchShow
licensePort --release 0
licensePort --show
switchEnable
switchShow
Switch activation and deactivation
switchDisable
switchEnable
port activation and deactivation
portDisable (or portEnable slot#/port#)
portEnable (or portEnable slot#/port#)
*** Basic Connections ***
NOTE:
before connecting a swtich to a fabric that contains switches running diff fw ve
rsions, make sure PID format is the same on all switches
configShow (to check PID format)
std or default ISL mode is L0
maximum ISL distances:
10km @ 1Gbps
5km @ 2Gbps
2.5km @ 4Gbps
ISL mode L0 avail on all fabric os releases
*** ISL Configuration, etc ***
Gateway links
a gateway merges SANs into a single fabric by establishing point-to-point E_Port
connectivity between two fibre channel switches that are sparated by a network
with a protocol such as IP or SONET except for link initialization, gatewas are
transparent to switches; the gateway simply provides e_port connectivity from on
switch to another. by default, switchports initialize links using the exchange
link parms (ELP) mode 1. however, gaeways expect initialization with ELP mode 2,
also referred to as ISL R_RDY mode. Therefore, to enable two swithes to link th
ru a gateway, the ports on both switches must be set for ELP mode 2
Any number of e_ports can be configured for gateway links, provided the follwoin
g guidelines are followed:
all switches in fabric must be upgraded to fabos v5.2.0 or later
all switches in fab are using cor PID format
swithes connected to both sides of gateway are included when determining switch
count maximums
extended links (thos created using the extended fabrics licensed feature) are no
t supported thru gateway links.
configuring a link through a gateway
enter configShow on all switches to make sure PID format is consistent across en
tire fabric. If necessary,k change pid format on any nonconforming switches
connect to switch at one end of gw
portCfgIslMode ( or <slot/port, mode> )
repeat 1 thru 3 for any add'l ports