Professional Documents
Culture Documents
Me1201 Engineering Thermodynamics - Uq - May June 2007
Me1201 Engineering Thermodynamics - Uq - May June 2007
c
.
e
m
o
in
g
n
e
s
te
2.
A rigid tank is insulated around both its sides and ends. It is separated
initially into two equal volumes by a partition. When one side contains 1 kg of
gas at 100 kPa and 345'C, the other side remains evacuated.If the partition is
removed, find final pressure and temperature.
3.
4.
5.
6.
7.
8.
9.
10.
o
N
PARTB-(5x16=80marks)
11. (a)
(i)
(ii)
m
o
Or
(b)
c
.
e
(i)
(ii )
n
i
g
n
e
12'(a)(i)Whataretheconditionsforreversibility?Explain.G)
(ii)
s
te
o
N
specificheatofoilis2.skJfi<gK.Thewaterenterstheheat
exchanger aL 2L"C. Determine the net change in the entropy due to
heat exchangeprocess,and the amount of work obtained if cooling
of oil is done by using the heat to run a carnot engine with sink
(8+4)
temperature of 21"C.
Or
(b)
@+2)
(i)
(ii)
D 4060
18. (a)
(i)
(ii)
(b)
14.
(a)
(i)
Draw Rankine cycle with one open type feed water heater. Assume
the condition of the steam before entering the turbine to be
(6)
superheated.Sketch the cycle on T-s diagram.
(ii)
In an ideai reheat cycle, the steam enters the turbine at 30 bar and
500.c. After expansion to 5 bar, the steam is reheated to 500'c and
then expandedto the condenserplessure of 0.1 bar. Determine the
cycle thermal efficiency, mass flow rate of steam. Take power
$ + 4)
output as 100 MW.
m
o
lb.
(a)
n
i
g
(6)
(i)
DeduceMaxwell's relations.
(ii)
Explain the Joule Thomson effect with the help of T-p diagram and
derive the expression for Joule Thomson coefficient. Show that the
G+4+2)
value ofthis coefficient for an ideal gas is zero'
n
e
s
te
Or
(b)
c
.
e
(i)
(ii)
Write down the van der Waal's equation of state for real gases and
how is it obtained from ideal gas equation by incorporating real gas
(2+4)
corrections?
(iii)
(i)
(ii)
@)
o
N
Or
D 4060
(b)
(i)
(ii)
m
o
c
.
e
n
i
g
n
e
s
te
o
N
D 4060