Guide to EN 499 - 1995. Covered electrodes for manual metal arc
welding of non-alloy and fine grain steels.
Se
7 05 Feo
2 toe te
3 | pree'ae | Reso
a | cher | oe
5 | SHBIim | ke.oc
B | SEs 14
5 oi 28 0c
é a0 86
a zi =
Mo, i 03-08
Sainte vlcs Sow nthe tab rin rasa as
ee | Se S|
5a = = 3 | EBS cctv som
S| isse = 3 BS er tary tet wa
2) Ss s 3 Sea e ee ee rotons
3) 88 8 2EN ISO 2560—A._ NOTES.
‘Symbol for strength & elongation of all-weld metal
Note 4
‘a. For yield strength, the lower yield (Ret) shall be used
‘when yielding occurs, otherwise the 0,2% proof
strength (Rpo,2) shall be used.
b. Gauge length is equal to five times the specimen
diameter.
‘Symbol for chemical composition of all-weld metal
Note 2.
a. If not specified, Mo < 0,2; Ni<0,3; Cr<0,2; V<0,05;
NbO,05; Cu<0,3
b_ Single values shown in the table mean maximum
values
c The results shall be rounded to the same number of
‘significant figures as in the specified value using the rules
according to ISO 31-0:1992, Annex B, Rule A
‘Symbol for nominal electrode efficiency and type of
current. Note 3
a In order to demonstrate operability on a.c., tests shall
be carried out with no load voltage higher than 65V.
b_a.c.= altemnatina current: d.c. = direct current.