This document discusses measuring the dimensions of fabricated components. It was written by Loo Ching Yun, a student with ID A15KM0130 in Section 4 for the course SKMM1912 Experimental Method. The document was created for the Faculty of Mechanical Engineering at Universiti Teknikal Malaysia.
This document discusses measuring the dimensions of fabricated components. It was written by Loo Ching Yun, a student with ID A15KM0130 in Section 4 for the course SKMM1912 Experimental Method. The document was created for the Faculty of Mechanical Engineering at Universiti Teknikal Malaysia.
This document discusses measuring the dimensions of fabricated components. It was written by Loo Ching Yun, a student with ID A15KM0130 in Section 4 for the course SKMM1912 Experimental Method. The document was created for the Faculty of Mechanical Engineering at Universiti Teknikal Malaysia.
Effect Of Α‑Al And Si Precipitates On Microstructural Evaluation And Corrosion Behavior Of Laser Powder Bed Fusion Printed Alsi10Mg Plates In Seawater Environment