Cross ribs are added to one-way slabs to better distribute applied and concentrated loads in the transverse direction. Cross ribs are typically 10 cm wide with bottom reinforcement equal to the main ribs and top reinforcement at least half of the bottom. Code specifies using one cross rib for spans up to 5 meters with loads up to 3 kN/m, and three cross ribs for spans over 7 meters with loads over 3 kN/m.
Original Description:
Civil Engineering Document
it is a structural research about cross ribs.
Cross ribs are added to one-way slabs to better distribute applied and concentrated loads in the transverse direction. Cross ribs are typically 10 cm wide with bottom reinforcement equal to the main ribs and top reinforcement at least half of the bottom. Code specifies using one cross rib for spans up to 5 meters with loads up to 3 kN/m, and three cross ribs for spans over 7 meters with loads over 3 kN/m.
Cross ribs are added to one-way slabs to better distribute applied and concentrated loads in the transverse direction. Cross ribs are typically 10 cm wide with bottom reinforcement equal to the main ribs and top reinforcement at least half of the bottom. Code specifies using one cross rib for spans up to 5 meters with loads up to 3 kN/m, and three cross ribs for spans over 7 meters with loads over 3 kN/m.
Transversal ribs or cross ribs are added to one way slabs for better distribution of the applied loads. They also help in distributing the concentrated loads due to walls in the transverse direction.
Cross rib reinforcement:
The bottom reinforcement is taken as the reinforcement of the main ribs. The top reinforcement is taken at least of the bottom reinforcement. Note: Cross rib is usually taken as 10 cm wide. When we use cross ribs: The arrangement of cross ribs as specified in code is given as the following:
Live Load (kN/m)
3 3 >3 >3
Span length (m)
5 >5 4 to 7 >7
Number of cross ribs
No cross ribs needed One cross rib One cross rib Three cross ribs