Professional Documents
Culture Documents
Appendix2 Fluid
Appendix2 Fluid
Fluid properties
Harald Asheim
2006
1.
Black-oil model
When fluids flow from the reservoir to the surface, pressure and temperature decrease. This
affects the gas/liquid equilibrium and the properties of the gas and liquid phases. The blackoil model enables estimation of these, from a minimum of input data.
The black-oil model employs 2 pseudo components.
1)
Oil which is usually defined as the produced oil, at stock tank conditions.
2)
Gas which then is defined as the produced gas at atmospheric standard conditions.
The basic modeling assumption is that the gas may dissolve in the liquid hydrocarbon phase,
but no oil will dissolve in the gaseous phase. This implies that the composition of the gaseous
phase is assumed the same at all pressure and temperatures.
The black-oil model assumption is reasonable for mixtures of heavy and light components,
like many reservoir oils. The assumption gets worse for mixtures containing much of
intermediate components (propane, butane), and is directly misleading for mixtures of light
and intermediate components typically found in condensate reservoirs. The basic modeling
assumptions lead to the following relationships for fluid volumes at flowing conditions
QL q o Bo q w Bw q o Bo Fw Bw
(1)
QG q g R s q o B g q o Rt Rs B g
(2)
where:
qo
qg
qw
Rt
Rs
Fw
Bo
Bg
Bw
:
:
:
:
:
:
:
:
:
In Eq. (1), the water is added to the liquid phase. Although some water will vaporize to the
gas phase, this is usually neglected. The surface densities of oil, water and gas are usually
available from measurements.
The fluid densities at flowing conditions can be derived from the volume relationships (1),
(2).
Fluid properties.doc
19.07.2016
221/HA/alb
2
G
g q g Rs qo
QG
(3)
Bg
g Rs q o w q w
QL
o g Rs w Fw
Bo Bw Fw
(4)
where:
o : surface oil density (kg/Sm3)
g : surface gas density (kg/Sm3)
w : surface water density (kg/Sm3)
2.
Gas solubility
As long as liquid and gas are in contact and in thermodynamic equilibrium, the liquid will be
gas saturated at the actual pressure and temperature. The saturation pressure for a gas-oil
system is the pressure at which the gas solubility equals the producing gas/oil ratio, Rt
Rs pb , T Rt
where:
pb : saturation pressure
T : fluid temperature
Fluid properties.doc
19.07.2016
221/HA/alb
(5)
3
Thus correlations for the gas solubility can be used to estimate the saturation pressure for a
given Rt, and vice versa. From basic thermodynamics the following solubility behaviour may
be expected.
a)
b)
c)
(6)
0.00590 g 10
where:
Rs
g
p
T
:
:
:
:
2.14 / o
10
cR p 1.4
1.205
0.00198 T
141.5
131.5
o
Standing found that the calibration constant, cR, depends on crude type. If PVT data are
available, this constant may be changed to match measurements.
Glas's correlation, for the input parameter units as above.
Rs
g
API 1.2120 1.8T 460 0.2108 103.518 1 1.2404 0.397 1og
5.615
10
0 .5
(7)
Glas /1980/ developed a correlation based on North Sea data from 6 different reservoirs. It
appears to be less consistent with general thermodynamic principles than Standings
correlation. Other solubility correlation has been given by Lasater /1958/ and by Vazquez and
Beggs /1977/.
Fluid properties.doc
19.07.2016
221/HA/alb
3.
When gas dissolves in the oil, the mass contained in oil phase increases. This makes the
pressure-volume behavior of liquid below the saturation pressure fundamentally different than
from above the saturation pressure. Figure 2 show a typical variation of the formation volume
factor with pressure.
Expansion of the liquid volume by the dissolved gas. This should be roughly
proportional to amount of gas dissolved and increase by increasing molecular size (mol
volume) of the gas.
b)
c)
The overall effect of pressure increase at constant temperature will be increased liquid
volume. Temperature increase at constant pressure will result in reduced liquid volume,
caused by vaporization. These fundamental mechanisms are quantified in the empirical
correlation by Standing /1947/.
Fluid properties.doc
19.07.2016
221/HA/alb
Standing's correlation, for input parameter units are as for Eq. (6) above.
Bo cB 0.952 10 g
o
0 .5
1 .2
Rs 0.401 T 103
(8)
where:
cB : calibration constant.
cB = 0.9759 estimated by Standing for California crudes
If PVT data are available, the calibration constant may be adjusted such that the estimates
match the measurements.
Glas's correlation
B 1 06.582.91log B*0.276log B*
10 10
(9)
B* 5.615
o
0.526
Rs 1.74 T 445
(10)
Glas /1980/ has developed a correlation based on data from 6 different North Sea reservoirs.
Again this appears to be less consistent with thermodynamic principles than Standings
correlation. Other correlations have been developed by Vazquez and Beggs /1977/.
Above the saturation pressure
Above the saturation pressure all gas will be in solution, and only a liquid oil phase present.
This liquid will compress with increasing pressure. The compressibility factor is generally
defined as
c
1 dV
1 dBo
V dp
Bo dp
Fluid properties.doc
19.07.2016
221/HA/alb
(11)
6
For ideal liquids, the compressibility factor is constant. Assuming constant compressibility,
the volume behavior above saturation pressure may be expressed by integrating (11). This
gives
Bo Bob e c p pb
(12)
where:
c : constant compressibility factor (1/bar)
pb : saturation pressure (bubble point pressure)
Bob : formation volume factor at saturation pressure
A compressibility factor correlation has been developed by Vazquez and Beggs /1980/.
c 10 4
(13)
(14)
Since the compressibility factor usually is very small, much difference between the two
approaches should not be expected. The latter (15) was recommended by Whitson & Brule /
2000/.
4.
(15)
The gas formation volume factor is by definition the ratio of volume at given temperature and
pressure, to volume at standard surface temperature and pressure. By the general gas equation,
this is expressed as
Fluid properties.doc
19.07.2016
221/HA/alb
7
Bg
where:
z
po T z
p T o zo
(16)
At surface conditions natural hydrocarbon gas behaves close to ideal. Thus, z 1 at surface
pressure. At downhole condition pressure, the z-factor is usually in the order of 0.7-0.9. For
natural gas mixtures, the z-factor can be estimated using the Standing-Katz correlation, Fig. 3.
Fluid properties.doc
19.07.2016
221/HA/alb
8
The pseudo reduced pressure and temperatures needed to estimate the z-factors are defined as
actual gas pressure divided by pseudo critical pressure, and actual gas temperature divided by
pseudo critical temperature. The pseudo critical pressure and temperature of gas mixtures are
defined as compositional averages of critical pressures and temperatures of individual
components.
When gas composition is not known, pseudo critical pressure and temperature may be
estimated based on gas gravity, implicitly assuming some typical composition. For associated
gas, such correlations have been worked out by Sutton/1985/. Associated gas usually has
relatively more heavy component than found in gas fields. Suttons correlations are given
below, algebraically and graphically
T pc 94.0 194.2 g 41.1 g2
p pc 58.18 9.032 g 0.248 g2
5.
Oil viscosity
The oil viscosity of dead (gas-free) oil is easily measured. However, to measure the viscosity
of gas-saturated oil at elevated pressure is much more complicated. Therefore, the oil
viscosity is often measured at surface pressure and reservoir temperature, and adjusted for gas
content.
Fluid properties.doc
19.07.2016
221/HA/alb
9
Chew and Connally /1959/ presented a graphical correlation to adjust the dead oil viscosity
according to the gas solubility. The correlation, as shown in Figure 4 was developed 457
crude oil samples.
(17)
where:
a 10 Rs 6.910
Rs 4.210 3
b 0.68 10 4.8410
Rs
0.25 10 6.1810
Rs
0.062 10 2.110
Rs
Beggs and Robinson /1975/ use the same correlation formula (14), but predict the parameters
slightly simple
Fluid properties.doc
19.07.2016
221/HA/alb
10
a
4.406
Rs 17.809 0.515
3.036
Rs 26.714 0.338
where:
os
od
Rs
The dead oil viscosity is preferably measured. There exist several correlations for the dead oil
viscosity as function of temperature and gravity. None of these are very reliable. According to
Sutton and Farashad /1984/, one of the better correlations is by Glas /1980/.
od
4.15 10 9
log10 API a
3.44
T 256
(18)
where
a = 10.313 log10 (T-256) - 33.81
Undersaturated oil
When all gas has been dissolved, further pressure increases will compress the oil, thus,
reducing the distance between molecules and increasing the viscosity. Oil viscosity above
saturation pressure may be predicted by Beals correlations, analytically expressed as
o os 10 3 0.35 os
1.6
0.55 os
0.56
p p
s
(19)
where:
os : viscosity of oil at saturated pressure (cp)
ps : saturation pressure (bar)
p : pressure (bar)
6.
Gas viscosity
The gas viscosity at elevated pressure and temperature is usually estimated using the charts by
Carr-Kobayashi-Burrows /1954/. Dempsey /1965/ expressed their chart
Fluid properties.doc
19.07.2016
221/HA/alb
11
g
a0 a1 p pr a2 p 2pr a3 p 3pr
ln T pr
1
a a p a p a p
a a p a p a p
T pr a4 a5 p pr a6 p 2pr a7 p 3pr
T pr2
T pr3
where:
Tpr
ppr
a0-a15
a0
a1
a2
a3
a4
a5
a6
a7
=
=
=
=
=
=
=
=
12
13
pr
pr
10
14
2
pr
2
pr
11
15
(20)
3
pr
3
pr
a8
a9
a10
a11
a12
a13
a14
a15
=
=
=
=
=
=
=
=
- 7.93385684 (10-1)
1.39643306
- 1.49144925 (10-1)
4.41015512 (10-3)
8.39387178 (10-2)
- 1.86408848 (10-1)
2.03367881 (10-2)
- 6.09579263 (10-4)
Standing /1977/ proposed a convenient correlation for calculating the viscosity of the natural
gas at atmospheric pressure and reservoir temperature
1 3.0764 10 5 3.712 10 6 g T 256
8.188 10 3 6.15 10 3 log 10 g
(21)
The pressure of non-hydrocarbon gases affects the viscosity. This can be corrected for as
follows.
Fluid properties.doc
19.07.2016
221/HA/alb
:
:
:
:
(22)
(23)
12
References
/1946/
Beal, C.:
"The Viscosity of Air, Water, Natural Gas, Crude Oil and its Associated Gases at Oil
Field Temperatures and Pressures", Trans. AIME, 165, 94 (1946).
/1947/
Standing, M.B.:
"A Pressure-Volume-Temperature Correlation for Mixtures of California Oils and
Gases",
API Drilling and Production pract. 1947, p. 247.
/1952/
Standing, M.B.:
"Volumetric Phase Behaviour of Oil Field Hydrocarbon Systems",
Chevron Research Company 1952.
/1954/
/1958/
Lasater, J.A.:
"Bubble Point Pressure Correlation",
Trans. AIME, 213, 1958, p.379-381.
/1959/
/1965/
Dempsey, J.R.:
Computer Routine Treats Gas Viscosity as a Variable,
O & G Journal, Aug. 16, 1965, p. 141.
/1967/
/1975/
Fluid properties.doc
19.07.2016
221/HA/alb
13
/1980/
Glas, .:
"Generalized Pressure-Volume-Temperature Correlations",
JPT, May 1980, p 784-795.
/1980/
/1981/
Standing, M.B.:
Volumetric and Phase Behaviour of Oil Field Hydrocarbon Systems,
Soc. Petr. Engin., Dallas, 1981.
/1984/
/2000/
Fluid properties.doc
19.07.2016
221/HA/alb